Signs of the Times - June 2017 - 26
VEHICLES + VINYL
seam, and that no part stretches
across it. Also, Craig writes, be
sure to reestablish a level baseline
once you have completed the seam,
as some of the vinyl may otherwise
become unevenly distributed.
TRIMMING
Once a panel is completely applied,
use a utility knife to trim away the
excess vinyl at the top edges along
the body-line of the vehicle. At the
bottom of the panel, wrap the vinyl
inside the wheel well, then apply the
panel for the lower portion of the
vehicle. Trim this graphic 3-4 in. past
the start of the wheel well so it will
tuck under and wrap around completely. Use a squeegee to apply the
vinyl until no more paint is visible.
Then, as Craig writes, make four or
five small vertical "relief cuts" along
the wheel well that will allow the
vinyl to "relax," making it easier to
wrap inside the well.
"For me, trimming is the most
tedious and difficult part of doing
a wrap," said Molly Waters, senior
technical specialist, Avery Dennison
Heating the vinyl causes it to "relax," conform to contours and adhere to
the vehicle.
Graphics Solutions. "Take your time
and think twice before trimming
away excess vinyl or making relief
cuts so you avoid any miscuts. A
slight miscut can cause the paint
from the vehicle to be visible and
possibly ruin all of your hard work."
There's no substitute for hands-on training with an experienced wrap installer,
such as Justin Pate of The Wrap Institute and the Avery Dennison/Mutoh
Wrap Training Program.
26
SIGNS OF THE TIMES
JUNE 2017
POST HEATING
With the panels installed, the next
step, post heating, calls for a heat gun
or propane torch. Keeping the tip of
the heat source 4-5 in. from the vinyl,
heat all of the areas where it was
stretched by more than 10%, as
well as the vinyl at the edges. Continue to heat the vinyl until you see
it relax, which should only take a few
seconds. It's crucial to keep the heat
moving back and forth over an 8-10 in.
section at all times. Leaving the heat on
one area for even slightly too long will
burn the vinyl, forcing you to replace
the entire panel. With the material now
warmed, work the portions into the
wheel well with gloved hands and down
along the edges with a rivet brush.
Repeat these techniques until all
the panels are installed, trimmed
and heated. Once you've mastered
the process, snap some pics of your
best projects and enter them in our
Vehicle Graphics Contest. The details
and entry form are on signweb.com
and the deadline is July 14, so get
wrapping and snapping!
http://www.signweb.com
Table of Contents for the Digital Edition of Signs of the Times - June 2017
Signs of the Times - June 2017
Contents
From the Editor
St Update
At Large
Tech Review
Vehicles + Vinyl
Design Matters
Nuts + Bolts
Trending Times Square
Smart Surroundings
Digital Sign Manufacturing
Strictly Electric: A Goodman Sign
New Products
Advertising Index
Last Look
Signs of the Times - June 2017 - Intro
Signs of the Times - June 2017 - BB1
Signs of the Times - June 2017 - BB2
Signs of the Times - June 2017 - Signs of the Times - June 2017
Signs of the Times - June 2017 - BD_L
Signs of the Times - June 2017 - BD
Signs of the Times - June 2017 - Cover2
Signs of the Times - June 2017 - 1
Signs of the Times - June 2017 - Contents
Signs of the Times - June 2017 - 3
Signs of the Times - June 2017 - 4
Signs of the Times - June 2017 - 5
Signs of the Times - June 2017 - 6
Signs of the Times - June 2017 - From the Editor
Signs of the Times - June 2017 - 8
Signs of the Times - June 2017 - 9
Signs of the Times - June 2017 - St Update
Signs of the Times - June 2017 - 11
Signs of the Times - June 2017 - 12
Signs of the Times - June 2017 - 13
Signs of the Times - June 2017 - 14
Signs of the Times - June 2017 - 15
Signs of the Times - June 2017 - 16
Signs of the Times - June 2017 - 17
Signs of the Times - June 2017 - At Large
Signs of the Times - June 2017 - 19
Signs of the Times - June 2017 - 20
Signs of the Times - June 2017 - 21
Signs of the Times - June 2017 - Tech Review
Signs of the Times - June 2017 - 23
Signs of the Times - June 2017 - Vehicles + Vinyl
Signs of the Times - June 2017 - 25
Signs of the Times - June 2017 - 26
Signs of the Times - June 2017 - 27
Signs of the Times - June 2017 - Design Matters
Signs of the Times - June 2017 - 29
Signs of the Times - June 2017 - Nuts + Bolts
Signs of the Times - June 2017 - 31
Signs of the Times - June 2017 - 32
Signs of the Times - June 2017 - 33
Signs of the Times - June 2017 - 34
Signs of the Times - June 2017 - 35
Signs of the Times - June 2017 - 36
Signs of the Times - June 2017 - 37
Signs of the Times - June 2017 - Trending Times Square
Signs of the Times - June 2017 - 39
Signs of the Times - June 2017 - 40
Signs of the Times - June 2017 - 41
Signs of the Times - June 2017 - 42
Signs of the Times - June 2017 - 43
Signs of the Times - June 2017 - 44
Signs of the Times - June 2017 - 45
Signs of the Times - June 2017 - 46
Signs of the Times - June 2017 - 47
Signs of the Times - June 2017 - Smart Surroundings
Signs of the Times - June 2017 - 49
Signs of the Times - June 2017 - 50
Signs of the Times - June 2017 - 51
Signs of the Times - June 2017 - Digital Sign Manufacturing
Signs of the Times - June 2017 - 53
Signs of the Times - June 2017 - 54
Signs of the Times - June 2017 - 55
Signs of the Times - June 2017 - 56
Signs of the Times - June 2017 - 57
Signs of the Times - June 2017 - Strictly Electric: A Goodman Sign
Signs of the Times - June 2017 - 59
Signs of the Times - June 2017 - 60
Signs of the Times - June 2017 - 61
Signs of the Times - June 2017 - 62
Signs of the Times - June 2017 - 63
Signs of the Times - June 2017 - New Products
Signs of the Times - June 2017 - 65
Signs of the Times - June 2017 - 66
Signs of the Times - June 2017 - 67
Signs of the Times - June 2017 - 68
Signs of the Times - June 2017 - 69
Signs of the Times - June 2017 - 70
Signs of the Times - June 2017 - 71
Signs of the Times - June 2017 - 72
Signs of the Times - June 2017 - 73
Signs of the Times - June 2017 - 74
Signs of the Times - June 2017 - 75
Signs of the Times - June 2017 - 76
Signs of the Times - June 2017 - 77
Signs of the Times - June 2017 - 78
Signs of the Times - June 2017 - 79
Signs of the Times - June 2017 - 80
Signs of the Times - June 2017 - 81
Signs of the Times - June 2017 - 82
Signs of the Times - June 2017 - 83
Signs of the Times - June 2017 - 84
Signs of the Times - June 2017 - 85
Signs of the Times - June 2017 - 86
Signs of the Times - June 2017 - 87
Signs of the Times - June 2017 - 88
Signs of the Times - June 2017 - 89
Signs of the Times - June 2017 - 90
Signs of the Times - June 2017 - 91
Signs of the Times - June 2017 - 92
Signs of the Times - June 2017 - 93
Signs of the Times - June 2017 - 94
Signs of the Times - June 2017 - 95
Signs of the Times - June 2017 - 96
Signs of the Times - June 2017 - 97
Signs of the Times - June 2017 - 98
Signs of the Times - June 2017 - Advertising Index
Signs of the Times - June 2017 - Last Look
Signs of the Times - June 2017 - Cover3
Signs of the Times - June 2017 - Cover4
https://www.nxtbook.com/nxtbooks/STMG/sott_202010
https://www.nxtbook.com/nxtbooks/STMG/sott_202009
https://www.nxtbook.com/nxtbooks/STMG/sott_202008
https://www.nxtbook.com/nxtbooks/STMG/sott_202007
https://www.nxtbook.com/nxtbooks/STMG/sott_202006
https://www.nxtbook.com/nxtbooks/STMG/sott_202005
https://www.nxtbook.com/nxtbooks/STMG/sott_202004
https://www.nxtbook.com/nxtbooks/STMG/sott_blackbook_2020
https://www.nxtbook.com/nxtbooks/STMG/sott_202003
https://www.nxtbook.com/nxtbooks/STMG/sott_201802
https://www.nxtbook.com/nxtbooks/STMG/sott_201801
https://www.nxtbook.com/nxtbooks/STMG/sott_201712
https://www.nxtbook.com/nxtbooks/STMG/sott_201711
https://www.nxtbook.com/nxtbooks/STMG/sott_201710
https://www.nxtbook.com/nxtbooks/STMG/sott_201709
https://www.nxtbook.com/nxtbooks/STMG/sott_201708
https://www.nxtbook.com/nxtbooks/STMG/sott_201707
https://www.nxtbook.com/nxtbooks/STMG/sott_201706
https://www.nxtbook.com/nxtbooks/STMG/sott_201705
https://www.nxtbook.com/nxtbooks/STMG/sott_201704
https://www.nxtbook.com/nxtbooks/STMG/sott_bg2017
https://www.nxtbook.com/nxtbooks/STMG/sott_201703
https://www.nxtbook.com/nxtbooks/STMG/sott_201702
https://www.nxtbook.com/nxtbooks/STMG/sott_201701
https://www.nxtbook.com/nxtbooks/STMG/sott_201612
https://www.nxtbook.com/nxtbooks/STMG/sott_201611
https://www.nxtbook.com/nxtbooks/STMG/sott_201610
https://www.nxtbook.com/nxtbooks/STMG/sott_201609
https://www.nxtbook.com/nxtbooks/STMG/sott_201608
https://www.nxtbook.com/nxtbooks/STMG/sott_201607
https://www.nxtbook.com/nxtbooks/STMG/sott_201606
https://www.nxtbook.com/nxtbooks/STMG/sott_201605
https://www.nxtbook.com/nxtbooks/STMG/sott_201604
https://www.nxtbook.com/nxtbooks/STMG/sott_201603
https://www.nxtbook.com/nxtbooks/STMG/sott_bg2016
https://www.nxtbook.com/nxtbooks/STMG/sott_201602
https://www.nxtbook.com/nxtbooks/STMG/sott_201601
https://www.nxtbook.com/nxtbooks/STMG/sott_201512
https://www.nxtbook.com/nxtbooks/STMG/sott_201511
https://www.nxtbook.com/nxtbooks/STMG/sott_201510
https://www.nxtbook.com/nxtbooks/STMG/sott_201509
https://www.nxtbook.com/nxtbooks/STMG/sott_201508
https://www.nxtbook.com/nxtbooks/STMG/sott_201507
https://www.nxtbook.com/nxtbooks/STMG/sott_201506
https://www.nxtbook.com/nxtbooks/STMG/sott_201505
https://www.nxtbook.com/nxtbooks/STMG/sott_201504
https://www.nxtbook.com/nxtbooks/STMG/sott_201503
https://www.nxtbook.com/nxtbooks/STMG/sott_bg2015
https://www.nxtbook.com/nxtbooks/STMG/sott_201502
https://www.nxtbook.com/nxtbooks/STMG/sott_201501
https://www.nxtbook.com/nxtbooks/STMG/sott_201412
https://www.nxtbook.com/nxtbooks/STMG/sott_201411
https://www.nxtbook.com/nxtbooks/STMG/sott_201410
https://www.nxtbook.com/nxtbooks/STMG/sott_201409
https://www.nxtbook.com/nxtbooks/STMG/sott_201408
https://www.nxtbook.com/nxtbooks/STMG/sott_201407
https://www.nxtbook.com/nxtbooks/STMG/sott_201406
https://www.nxtbook.com/nxtbooks/STMG/sott_201405
https://www.nxtbook.com/nxtbooks/STMG/sott_201404
https://www.nxtbook.com/nxtbooks/STMG/sott_201403
https://www.nxtbook.com/nxtbooks/STMG/sott_bg2014
https://www.nxtbook.com/nxtbooks/STMG/sott_201402
https://www.nxtbook.com/nxtbooks/STMG/sott_201401
https://www.nxtbook.com/nxtbooks/STMG/sott_201312
https://www.nxtbook.com/nxtbooks/STMG/sott_201311
https://www.nxtbook.com/nxtbooks/STMG/sott_201310
https://www.nxtbook.com/nxtbooks/STMG/sott_201309
https://www.nxtbook.com/nxtbooks/STMG/sott_201308
https://www.nxtbook.com/nxtbooks/STMG/sott_201307
https://www.nxtbook.com/nxtbooks/STMG/sott_201306
https://www.nxtbook.com/nxtbooks/STMG/sott_201305
https://www.nxtbook.com/nxtbooks/STMG/sott_201304
https://www.nxtbook.com/nxtbooks/STMG/sott_201303
https://www.nxtbook.com/nxtbooks/STMG/sott_bg2013
https://www.nxtbook.com/nxtbooks/STMG/sott_201302
https://www.nxtbook.com/nxtbooks/STMG/sott_201301
https://www.nxtbook.com/nxtbooks/STMG/sott_201212
https://www.nxtbook.com/nxtbooks/STMG/sott_201211
https://www.nxtbook.com/nxtbooks/STMG/sott_201210
https://www.nxtbook.com/nxtbooks/STMG/sott_201209
https://www.nxtbook.com/nxtbooks/STMG/sott_201208
https://www.nxtbook.com/nxtbooks/STMG/sott_201207
https://www.nxtbook.com/nxtbooks/STMG/sott_201206
https://www.nxtbook.com/nxtbooks/STMG/sott_201205
https://www.nxtbook.com/nxtbooks/STMG/sott_201204
https://www.nxtbook.com/nxtbooks/STMG/sott_201203
https://www.nxtbook.com/nxtbooks/STMG/sott_bg2012
https://www.nxtbook.com/nxtbooks/STMG/sott_201202
https://www.nxtbook.com/nxtbooks/STMG/sott_201201
https://www.nxtbookmedia.com