American Oil & Gas Reporter - December 2011 - 111

SpecialReport: Well Stimulation & Completion Technology

RI-RDF Excels In Horizontal ERD Wells
By Marc Kuck, Mark Luyster, Arvind D. Patel, Sooi Kim Lim, Ray Ravitz and Hal Martens ANCHORAGE, AK.–The successful drilling and completion of two extended-reach horizontal injector wells in the Nikaitchuq Field offshore the Alaska North Slope overcame a myriad of technical hurdles, not the least of which were severe frictional forces that conceivably could inhibit or even prevent the drill pipe and lower completion assembly from reaching target depth. The complexity of the completion design in the challenging viscous oil waterflood project made flow back or postdrilling intervention for clean up undesirable. Consequently, facilitating direct injection mandated the development of a specially engineered delayed-breaker system used in conjunction with a unique, reversible invert reservoir drill-in fluid (RI-RDF) system. The reservoir drill-in fluid delivered low torque and exceptional drilling efficiency while in the 81⁄2-inch ERD horizontals. Moreover, the breaker system provided the delay necessary to allow spotting in the open-hole horizontal section prior to installing the liner and lower completion injection control assembly without requiring flow back. The RI-RDF and breaker tandem met all drilling and completion objectives, and as importantly, provided valuable insight to advance the understanding of injection behavior in extended-reach viscous oil environments. ENI Petroleum holds a 100 percent working interest in the Nikaitchuq Field in the Beaufort Sea (Figure 1). The primary reservoirs are the “OA” and “N” Cretaceous sands. The targeted injectors were drilled in the OA sand, which is primarily a litharenite characterized by framework mineralogy that includes pervasive rock fragments, angular quartz, scattered feldspar (plagioclase) and accessory grains. The median grain size shows that this sand varies from a coarse siltstone to a fine-grained sandstone. The gross thickness of the OA sand ranges from 35 to 47 feet with net-togross ranges of 65 to 93 percent. Porosity ranges from 24 to 35 percent while permeability is between 92 to 627 mD. Intergranular porosity is variably preserved. The water saturation ranges from 23 to 45 percent, with the latter most likely representative of a transition zone. Hydrocarbons in the OA sands are viscous, averaging approximately 16-19 degrees API gravity with 100-180 centipoise (85 degrees Fahrenheit) at reservoir depth, and characterized by a low gasto-oil ratio of 70-150 cubic feet/barrel. Development Strategy The Nikaitchuq Field development strategy called for drilling a series of producer and injector wells from the Spy Island (SI) artificial island and the nearby Oliktok Point Pad (OPP). Because of well-specific monitoring equipment, the injectors for SI and OPP required different design and installation methods. This article focuses on the OPP OI11-01 and OI07-04 injection wells, which comprised both monitoring and injection control features. The lower completion design of the OPP injectors included a distributed temperature sensor (DTS) monitoring system along the entire length of the well bore, with pressure gauges located at the heel and toe. The horizontal sections incorporated 51⁄2-inch slotted liners with a 31⁄2inch string inside the liner to convey the monitoring equipment, isolation packers FIGURE 1 Nikaitchuq Field (Beaufort Sea) and injection control devices (ICDs). As part of ENI Petroleum’s monitoring strategy, a fiber-optic DTS was deployed to measure the temperature distribution along the lateral section. The complexity of the completions, particularly the use of ICDs and packers, removed flow back for clean up as a viable option. While the extended-reach wells were planned to be drilled with profiles of 10,000-12,000 feet measured depth, the proposed target depth was between 3,500 and 3,900 feet total vertical depth. The resulting ratio disparity equated to a horizontal depth-to-TVD ratio of 2.0 to 3.6. As the HD/TVD ratio increases, so does the difficulty in both drilling and completing a well. The increased frictional forces can even prevent drill pipe and lower completion assemblies from reaching target depth. Since the style of completion for the injector wells was not conducive for flow back prior to initiating injection, these wells represented the most technically demanding aspect of the entire field development. Upfront Planning Objectives During the exhaustive preplanning phase, ENI Petroleum established as primary objectives the distribution of injection across the entire length of the horizontal completion, as well as the capacity to in-

DECEMBER 2011 111



Table of Contents for the Digital Edition of American Oil & Gas Reporter - December 2011

American Oil and Gas Reporter 12/11
Contents
Reports
Calendar
Oil & Gas Counts
State Legislative
Industry Digest
Tech Connections
Washington Watch
Keystone XL
Liaison Committee
Shale Gas Subcommittee
Endangered Species
Midstream Startups Emerging to Meet Booming Demand
Liquids Resource Plays Have Oil Production Rising Again
Organizers Anticipating Big Things for 2012 PBIOS
Cover Story
R&D Areas Key to Improving Fracturing
Natural Gas Offers Solutions as Transportation Fuel
Completion Design, Frac Modeling Optimize Eagle Ford Wells
Novel Drill-In Fluid Excels in Horizontal ERD Wells
Technologies Optimize Sand Control
Operators Must Manage Risk Before, During and After Drilling
OCS Access: BOEM Offers Business-as-Usual OCS Leasing Plan
Court Finds for Insurers in Gulf Spill Ruling
OIPA
Clean Air Act
IOGA NY
COGA
IPAA Annual
Louisiana
West Virginia
Pennsylvania
Texas
The American Well Servicing Directory, Winter 2011
Industry Focus
Classified Advertising
Advertisers Index
American Oil & Gas Reporter - December 2011 - American Oil and Gas Reporter 12/11
American Oil & Gas Reporter - December 2011 - Cover2
American Oil & Gas Reporter - December 2011 - Contents
American Oil & Gas Reporter - December 2011 - Reports
American Oil & Gas Reporter - December 2011 - 5
American Oil & Gas Reporter - December 2011 - 6
American Oil & Gas Reporter - December 2011 - 7
American Oil & Gas Reporter - December 2011 - Calendar
American Oil & Gas Reporter - December 2011 - 9
American Oil & Gas Reporter - December 2011 - 10
American Oil & Gas Reporter - December 2011 - 11
American Oil & Gas Reporter - December 2011 - Oil & Gas Counts
American Oil & Gas Reporter - December 2011 - 13
American Oil & Gas Reporter - December 2011 - Industry Digest
American Oil & Gas Reporter - December 2011 - 15
American Oil & Gas Reporter - December 2011 - 16
American Oil & Gas Reporter - December 2011 - 17
American Oil & Gas Reporter - December 2011 - 18
American Oil & Gas Reporter - December 2011 - 19
American Oil & Gas Reporter - December 2011 - 20
American Oil & Gas Reporter - December 2011 - 21
American Oil & Gas Reporter - December 2011 - 22
American Oil & Gas Reporter - December 2011 - 23
American Oil & Gas Reporter - December 2011 - 24
American Oil & Gas Reporter - December 2011 - 25
American Oil & Gas Reporter - December 2011 - 26
American Oil & Gas Reporter - December 2011 - 27
American Oil & Gas Reporter - December 2011 - 28
American Oil & Gas Reporter - December 2011 - Tech Connections
American Oil & Gas Reporter - December 2011 - 30
American Oil & Gas Reporter - December 2011 - Washington Watch
American Oil & Gas Reporter - December 2011 - Keystone XL
American Oil & Gas Reporter - December 2011 - 33
American Oil & Gas Reporter - December 2011 - Liaison Committee
American Oil & Gas Reporter - December 2011 - 35
American Oil & Gas Reporter - December 2011 - 36
American Oil & Gas Reporter - December 2011 - 37
American Oil & Gas Reporter - December 2011 - Shale Gas Subcommittee
American Oil & Gas Reporter - December 2011 - 39
American Oil & Gas Reporter - December 2011 - Endangered Species
American Oil & Gas Reporter - December 2011 - 41
American Oil & Gas Reporter - December 2011 - Midstream Startups Emerging to Meet Booming Demand
American Oil & Gas Reporter - December 2011 - 43
American Oil & Gas Reporter - December 2011 - 44
American Oil & Gas Reporter - December 2011 - 45
American Oil & Gas Reporter - December 2011 - 46
American Oil & Gas Reporter - December 2011 - 47
American Oil & Gas Reporter - December 2011 - 48
American Oil & Gas Reporter - December 2011 - 49
American Oil & Gas Reporter - December 2011 - 50
American Oil & Gas Reporter - December 2011 - 51
American Oil & Gas Reporter - December 2011 - 52
American Oil & Gas Reporter - December 2011 - 53
American Oil & Gas Reporter - December 2011 - 54
American Oil & Gas Reporter - December 2011 - 55
American Oil & Gas Reporter - December 2011 - 56
American Oil & Gas Reporter - December 2011 - 57
American Oil & Gas Reporter - December 2011 - Liquids Resource Plays Have Oil Production Rising Again
American Oil & Gas Reporter - December 2011 - 59
American Oil & Gas Reporter - December 2011 - 60
American Oil & Gas Reporter - December 2011 - 61
American Oil & Gas Reporter - December 2011 - 62
American Oil & Gas Reporter - December 2011 - 63
American Oil & Gas Reporter - December 2011 - 64
American Oil & Gas Reporter - December 2011 - 65
American Oil & Gas Reporter - December 2011 - 66
American Oil & Gas Reporter - December 2011 - 67
American Oil & Gas Reporter - December 2011 - 68
American Oil & Gas Reporter - December 2011 - 69
American Oil & Gas Reporter - December 2011 - 70
American Oil & Gas Reporter - December 2011 - 71
American Oil & Gas Reporter - December 2011 - 72
American Oil & Gas Reporter - December 2011 - Organizers Anticipating Big Things for 2012 PBIOS
American Oil & Gas Reporter - December 2011 - Cover Story
American Oil & Gas Reporter - December 2011 - 75
American Oil & Gas Reporter - December 2011 - 76
American Oil & Gas Reporter - December 2011 - 77
American Oil & Gas Reporter - December 2011 - 78
American Oil & Gas Reporter - December 2011 - 79
American Oil & Gas Reporter - December 2011 - 80
American Oil & Gas Reporter - December 2011 - 81
American Oil & Gas Reporter - December 2011 - 82
American Oil & Gas Reporter - December 2011 - R&D Areas Key to Improving Fracturing
American Oil & Gas Reporter - December 2011 - 84
American Oil & Gas Reporter - December 2011 - 85
American Oil & Gas Reporter - December 2011 - 86
American Oil & Gas Reporter - December 2011 - 87
American Oil & Gas Reporter - December 2011 - 88
American Oil & Gas Reporter - December 2011 - 89
American Oil & Gas Reporter - December 2011 - 90
American Oil & Gas Reporter - December 2011 - Natural Gas Offers Solutions as Transportation Fuel
American Oil & Gas Reporter - December 2011 - 92
American Oil & Gas Reporter - December 2011 - 93
American Oil & Gas Reporter - December 2011 - 94
American Oil & Gas Reporter - December 2011 - 95
American Oil & Gas Reporter - December 2011 - Completion Design, Frac Modeling Optimize Eagle Ford Wells
American Oil & Gas Reporter - December 2011 - 97
American Oil & Gas Reporter - December 2011 - 98
American Oil & Gas Reporter - December 2011 - 99
American Oil & Gas Reporter - December 2011 - 100
American Oil & Gas Reporter - December 2011 - 101
American Oil & Gas Reporter - December 2011 - 102
American Oil & Gas Reporter - December 2011 - 103
American Oil & Gas Reporter - December 2011 - 104
American Oil & Gas Reporter - December 2011 - 105
American Oil & Gas Reporter - December 2011 - 106
American Oil & Gas Reporter - December 2011 - 107
American Oil & Gas Reporter - December 2011 - 108
American Oil & Gas Reporter - December 2011 - 109
American Oil & Gas Reporter - December 2011 - 110
American Oil & Gas Reporter - December 2011 - Novel Drill-In Fluid Excels in Horizontal ERD Wells
American Oil & Gas Reporter - December 2011 - 112
American Oil & Gas Reporter - December 2011 - 113
American Oil & Gas Reporter - December 2011 - 114
American Oil & Gas Reporter - December 2011 - 115
American Oil & Gas Reporter - December 2011 - 116
American Oil & Gas Reporter - December 2011 - Technologies Optimize Sand Control
American Oil & Gas Reporter - December 2011 - 118
American Oil & Gas Reporter - December 2011 - 119
American Oil & Gas Reporter - December 2011 - 120
American Oil & Gas Reporter - December 2011 - 121
American Oil & Gas Reporter - December 2011 - Operators Must Manage Risk Before, During and After Drilling
American Oil & Gas Reporter - December 2011 - 123
American Oil & Gas Reporter - December 2011 - 124
American Oil & Gas Reporter - December 2011 - 125
American Oil & Gas Reporter - December 2011 - 126
American Oil & Gas Reporter - December 2011 - 127
American Oil & Gas Reporter - December 2011 - 128
American Oil & Gas Reporter - December 2011 - OCS Access: BOEM Offers Business-as-Usual OCS Leasing Plan
American Oil & Gas Reporter - December 2011 - Court Finds for Insurers in Gulf Spill Ruling
American Oil & Gas Reporter - December 2011 - 131
American Oil & Gas Reporter - December 2011 - 132
American Oil & Gas Reporter - December 2011 - OIPA
American Oil & Gas Reporter - December 2011 - 134
American Oil & Gas Reporter - December 2011 - 135
American Oil & Gas Reporter - December 2011 - Clean Air Act
American Oil & Gas Reporter - December 2011 - 137
American Oil & Gas Reporter - December 2011 - IOGA NY
American Oil & Gas Reporter - December 2011 - 139
American Oil & Gas Reporter - December 2011 - 140
American Oil & Gas Reporter - December 2011 - 141
American Oil & Gas Reporter - December 2011 - 142
American Oil & Gas Reporter - December 2011 - 143
American Oil & Gas Reporter - December 2011 - COGA
American Oil & Gas Reporter - December 2011 - 145
American Oil & Gas Reporter - December 2011 - 146
American Oil & Gas Reporter - December 2011 - IPAA Annual
American Oil & Gas Reporter - December 2011 - 148
American Oil & Gas Reporter - December 2011 - 149
American Oil & Gas Reporter - December 2011 - 150
American Oil & Gas Reporter - December 2011 - 151
American Oil & Gas Reporter - December 2011 - Louisiana
American Oil & Gas Reporter - December 2011 - 153
American Oil & Gas Reporter - December 2011 - 154
American Oil & Gas Reporter - December 2011 - 155
American Oil & Gas Reporter - December 2011 - West Virginia
American Oil & Gas Reporter - December 2011 - 157
American Oil & Gas Reporter - December 2011 - Pennsylvania
American Oil & Gas Reporter - December 2011 - Texas
American Oil & Gas Reporter - December 2011 - 160
American Oil & Gas Reporter - December 2011 - The American Well Servicing Directory, Winter 2011
American Oil & Gas Reporter - December 2011 - 162
American Oil & Gas Reporter - December 2011 - 163
American Oil & Gas Reporter - December 2011 - 164
American Oil & Gas Reporter - December 2011 - 165
American Oil & Gas Reporter - December 2011 - 166
American Oil & Gas Reporter - December 2011 - 167
American Oil & Gas Reporter - December 2011 - 168
American Oil & Gas Reporter - December 2011 - 169
American Oil & Gas Reporter - December 2011 - 170
American Oil & Gas Reporter - December 2011 - 171
American Oil & Gas Reporter - December 2011 - 172
American Oil & Gas Reporter - December 2011 - 173
American Oil & Gas Reporter - December 2011 - 174
American Oil & Gas Reporter - December 2011 - 175
American Oil & Gas Reporter - December 2011 - 176
American Oil & Gas Reporter - December 2011 - 177
American Oil & Gas Reporter - December 2011 - 178
American Oil & Gas Reporter - December 2011 - 179
American Oil & Gas Reporter - December 2011 - 180
American Oil & Gas Reporter - December 2011 - 181
American Oil & Gas Reporter - December 2011 - 182
American Oil & Gas Reporter - December 2011 - 183
American Oil & Gas Reporter - December 2011 - 184
American Oil & Gas Reporter - December 2011 - 185
American Oil & Gas Reporter - December 2011 - Industry Focus
American Oil & Gas Reporter - December 2011 - 187
American Oil & Gas Reporter - December 2011 - 188
American Oil & Gas Reporter - December 2011 - 189
American Oil & Gas Reporter - December 2011 - 190
American Oil & Gas Reporter - December 2011 - 191
American Oil & Gas Reporter - December 2011 - Classified Advertising
American Oil & Gas Reporter - December 2011 - 193
American Oil & Gas Reporter - December 2011 - Advertisers Index
American Oil & Gas Reporter - December 2011 - Cover3
American Oil & Gas Reporter - December 2011 - Cover4
http://www.nxtbook.com/nxtbooks/aogr/201909
http://www.nxtbook.com/nxtbooks/aogr/201908
http://www.nxtbook.com/nxtbooks/aogr/201907
http://www.nxtbook.com/nxtbooks/aogr/201906
http://www.nxtbook.com/nxtbooks/aogr/201905
http://www.nxtbook.com/nxtbooks/aogr/201904
http://www.nxtbook.com/nxtbooks/aogr/201903
http://www.nxtbook.com/nxtbooks/aogr/201902
http://www.nxtbook.com/nxtbooks/aogr/201901
http://www.nxtbook.com/nxtbooks/aogr/201812
http://www.nxtbook.com/nxtbooks/aogr/201811
http://www.nxtbook.com/nxtbooks/aogr/201810
http://www.nxtbook.com/nxtbooks/aogr/pbios_201810
http://www.nxtbook.com/nxtbooks/aogr/201809
http://www.nxtbook.com/nxtbooks/aogr/201808
http://www.nxtbook.com/nxtbooks/aogr/201807
http://www.nxtbook.com/nxtbooks/aogr/201806
http://www.nxtbook.com/nxtbooks/aogr/201805
http://www.nxtbook.com/nxtbooks/aogr/201804
http://www.nxtbook.com/nxtbooks/aogr/201803
http://www.nxtbook.com/nxtbooks/aogr/201802
http://www.nxtbook.com/nxtbooks/aogr/201801
http://www.nxtbook.com/nxtbooks/aogr/201712
http://www.nxtbook.com/nxtbooks/aogr/201711
http://www.nxtbook.com/nxtbooks/aogr/201710
http://www.nxtbook.com/nxtbooks/aogr/201709
http://www.nxtbook.com/nxtbooks/aogr/201708
http://www.nxtbook.com/nxtbooks/aogr/201707
http://www.nxtbook.com/nxtbooks/aogr/201706
http://www.nxtbook.com/nxtbooks/aogr/201705
http://www.nxtbook.com/nxtbooks/aogr/201704
http://www.nxtbook.com/nxtbooks/aogr/201703
http://www.nxtbook.com/nxtbooks/aogr/201702
http://www.nxtbook.com/nxtbooks/aogr/201701
http://www.nxtbook.com/nxtbooks/aogr/201612
http://www.nxtbook.com/nxtbooks/aogr/201611
http://www.nxtbook.com/nxtbooks/aogr/201610
http://www.nxtbook.com/nxtbooks/aogr/pbios2016_programguide
http://www.nxtbook.com/nxtbooks/aogr/201609
http://www.nxtbook.com/nxtbooks/aogr/201608
http://www.nxtbook.com/nxtbooks/aogr/201607
http://www.nxtbook.com/nxtbooks/aogr/201606
http://www.nxtbook.com/nxtbooks/aogr/201605
http://www.nxtbook.com/nxtbooks/aogr/201604
http://www.nxtbook.com/nxtbooks/aogr/201603
http://www.nxtbook.com/nxtbooks/aogr/201602
http://www.nxtbook.com/nxtbooks/aogr/201601
http://www.nxtbook.com/nxtbooks/aogr/201512
http://www.nxtbook.com/nxtbooks/aogr/201511
http://www.nxtbook.com/nxtbooks/aogr/201510
http://www.nxtbook.com/nxtbooks/aogr/201509
http://www.nxtbook.com/nxtbooks/aogr/201508
http://www.nxtbook.com/nxtbooks/aogr/201507
http://www.nxtbook.com/nxtbooks/aogr/201506
http://www.nxtbook.com/nxtbooks/aogr/201505
http://www.nxtbook.com/nxtbooks/aogr/201504
http://www.nxtbook.com/nxtbooks/aogr/201503
http://www.nxtbook.com/nxtbooks/aogr/201502
http://www.nxtbook.com/nxtbooks/aogr/201501
http://www.nxtbook.com/nxtbooks/aogr/201412
http://www.nxtbook.com/nxtbooks/aogr/201411
http://www.nxtbook.com/nxtbooks/aogr/201410
http://www.nxtbook.com/nxtbooks/aogr/201409
http://www.nxtbook.com/nxtbooks/aogr/pbios2014_programguide
http://www.nxtbook.com/nxtbooks/aogr/201408
http://www.nxtbook.com/nxtbooks/aogr/201407
http://www.nxtbook.com/nxtbooks/aogr/201406
http://www.nxtbook.com/nxtbooks/aogr/201405
http://www.nxtbook.com/nxtbooks/aogr/201404
http://www.nxtbook.com/nxtbooks/aogr/201403
http://www.nxtbook.com/nxtbooks/aogr/201402
http://www.nxtbook.com/nxtbooks/aogr/201401
http://www.nxtbook.com/nxtbooks/aogr/201312
http://www.nxtbook.com/nxtbooks/aogr/201311
http://www.nxtbook.com/nxtbooks/aogr/201310
http://www.nxtbook.com/nxtbooks/aogr/201309
http://www.nxtbook.com/nxtbooks/aogr/201308
http://www.nxtbook.com/nxtbooks/aogr/201307
http://www.nxtbook.com/nxtbooks/aogr/201306
http://www.nxtbook.com/nxtbooks/aogr/201305
http://www.nxtbook.com/nxtbooks/aogr/201304
http://www.nxtbook.com/nxtbooks/aogr/201303
http://www.nxtbook.com/nxtbooks/aogr/201302
http://www.nxtbook.com/nxtbooks/aogr/201301
http://www.nxtbook.com/nxtbooks/aogr/201212
http://www.nxtbook.com/nxtbooks/aogr/201211
http://www.nxtbook.com/nxtbooks/aogr/201210
http://www.nxtbook.com/nxtbooks/aogr/201209
http://www.nxtbook.com/nxtbooks/aogr/2012_pbios
http://www.nxtbook.com/nxtbooks/aogr/201208
http://www.nxtbook.com/nxtbooks/aogr/201207
http://www.nxtbook.com/nxtbooks/aogr/201206
http://www.nxtbook.com/nxtbooks/aogr/201205
http://www.nxtbook.com/nxtbooks/aogr/201204
http://www.nxtbook.com/nxtbooks/aogr/201203
http://www.nxtbook.com/nxtbooks/aogr/201202
http://www.nxtbook.com/nxtbooks/aogr/201201
http://www.nxtbook.com/nxtbooks/demo/aogr_clone
http://www.nxtbook.com/nxtbooks/aogr/201112
http://www.nxtbookMEDIA.com