American Oil & Gas Reporter - December 2011 - 114

SpecialReport: Well Stimulation & Completion Technology
regular emulsion in the presence of acid. Before its selection, the RI-RDF underwent a field reversibility test using a concentrated citric acid solution. This test determines the minimum amount of acid required to convert an RI-RDF system from an invert emulsion to a direct emulsion. The less acid required is an indication of the readiness for reversibility to a water-wet state. Results from testing of freshly prepared laboratory samples containing no formation solids showed reversal to a water-wet state required as little as five milliliters of acid in a 50-mL sample. The samples also exhibited electrical stability (ES) values of less than 10 volts, remarkably lower than the 200-800 volt values typically seen in the field. The ES value is used as an indicator of the relative integrity of the RI-RDF system, with higher ES values suggesting a stronger and more difficult-to-reverse emulsion. Breaker System The chief objective during this stage of the investigation was to develop and test a breaker system that would reduce friction with an extended delay, but also dissolve and degrade the residual filter cake using either an aqueous-based AGAP or invert-based I-GAP acid precursor. The desired breaker needed to provide effective displacement of the residual RDF from the lateral section, preferably using the rig pumps and also deliver positive well bore hydrostatic without the need for fluid loss control pills. The predominate requirements, however, were to provide the requisite delay so the lower completion installation could proceed without the filter cake degrading prematurely and creating losses, and provide complete dissolution to clear the way for direct injection. Typically, nondamaging esters are preferred in water-based RDF systems to degrade and dissolve residual filter cakes. Esters hydrolyze with time, temperature, and/or upon commingling with an aqueous fluid yielding an acid as well as an alcohol or glycol. Therefore, esters were shown to be ideal for enabling reversibility of the RI-RDF. The breaker assessment showed a glycol acid precursor (GAP) not only provided a delay, but also yielded the ability to vary the reaction rate and mitigate corrosion, emulsions and incompatibility with reservoir or completion fluids. These breaker systems are formulated and spotted in horizontal completions using either the A-GAP brine or aqueous-based or with I-GAP using oil and brine as an invert emulsion. Early in the testing, a matrix was formulated to include potential delay mechanisms for both I-GAP and A-GAP systems. Four products were identified, comprising a surface tension reducer, lubricant, surfactant and hydroxyethyl cellulose (HEC). The primary components included the GAP and a sequester, which were FIGURE 3A Rheological Properties Recorded While Drilling Well OI11-01 8½-inch Horizontal
45
6 RPM

formulated using the same concentration. Monovalent brines (potassium chloride and sodium chloride) were used as a base for the A-GAP and calcium chloride as the discontinuous phase of the I-GAP. For this test only, sodium bromide was used for the I-GAP. After a series of extended soaking, friction and injection tests using both AGAP and I-GAP formulations, the latter

40 35 30 25 20 15 10 5 0 6,384 6,453 6,574 6,814 7,523 8,001 8,506 9,151 Depth Drilled (ft)

3 RPM Plastic Viscosity cP Yield Point Lb/100 ft2 10 min Gel Strength Lb/100 ft2

Value

9,533 10,364 10,592 10,594

FIGURE 3B Rheological Properties Recorded While Drilling Well OI07-04 8½-inch Horizontal
45 40 35 30 25 20 15 10 5 0 5,953 6,597 7,639 8,520 8,873 9,425 10,091 Depth Drilled (ft) 10,723 11,403 11,869 12,325
6 RPM, cP 3 RPM, cP Plastic Viscosity Yield Point 10 min Gel Strength

114 THE AMERICAN OIL & GAS REPORTER

Value



Table of Contents for the Digital Edition of American Oil & Gas Reporter - December 2011

American Oil and Gas Reporter 12/11
Contents
Reports
Calendar
Oil & Gas Counts
State Legislative
Industry Digest
Tech Connections
Washington Watch
Keystone XL
Liaison Committee
Shale Gas Subcommittee
Endangered Species
Midstream Startups Emerging to Meet Booming Demand
Liquids Resource Plays Have Oil Production Rising Again
Organizers Anticipating Big Things for 2012 PBIOS
Cover Story
R&D Areas Key to Improving Fracturing
Natural Gas Offers Solutions as Transportation Fuel
Completion Design, Frac Modeling Optimize Eagle Ford Wells
Novel Drill-In Fluid Excels in Horizontal ERD Wells
Technologies Optimize Sand Control
Operators Must Manage Risk Before, During and After Drilling
OCS Access: BOEM Offers Business-as-Usual OCS Leasing Plan
Court Finds for Insurers in Gulf Spill Ruling
OIPA
Clean Air Act
IOGA NY
COGA
IPAA Annual
Louisiana
West Virginia
Pennsylvania
Texas
The American Well Servicing Directory, Winter 2011
Industry Focus
Classified Advertising
Advertisers Index
American Oil & Gas Reporter - December 2011 - American Oil and Gas Reporter 12/11
American Oil & Gas Reporter - December 2011 - Cover2
American Oil & Gas Reporter - December 2011 - Contents
American Oil & Gas Reporter - December 2011 - Reports
American Oil & Gas Reporter - December 2011 - 5
American Oil & Gas Reporter - December 2011 - 6
American Oil & Gas Reporter - December 2011 - 7
American Oil & Gas Reporter - December 2011 - Calendar
American Oil & Gas Reporter - December 2011 - 9
American Oil & Gas Reporter - December 2011 - 10
American Oil & Gas Reporter - December 2011 - 11
American Oil & Gas Reporter - December 2011 - Oil & Gas Counts
American Oil & Gas Reporter - December 2011 - 13
American Oil & Gas Reporter - December 2011 - Industry Digest
American Oil & Gas Reporter - December 2011 - 15
American Oil & Gas Reporter - December 2011 - 16
American Oil & Gas Reporter - December 2011 - 17
American Oil & Gas Reporter - December 2011 - 18
American Oil & Gas Reporter - December 2011 - 19
American Oil & Gas Reporter - December 2011 - 20
American Oil & Gas Reporter - December 2011 - 21
American Oil & Gas Reporter - December 2011 - 22
American Oil & Gas Reporter - December 2011 - 23
American Oil & Gas Reporter - December 2011 - 24
American Oil & Gas Reporter - December 2011 - 25
American Oil & Gas Reporter - December 2011 - 26
American Oil & Gas Reporter - December 2011 - 27
American Oil & Gas Reporter - December 2011 - 28
American Oil & Gas Reporter - December 2011 - Tech Connections
American Oil & Gas Reporter - December 2011 - 30
American Oil & Gas Reporter - December 2011 - Washington Watch
American Oil & Gas Reporter - December 2011 - Keystone XL
American Oil & Gas Reporter - December 2011 - 33
American Oil & Gas Reporter - December 2011 - Liaison Committee
American Oil & Gas Reporter - December 2011 - 35
American Oil & Gas Reporter - December 2011 - 36
American Oil & Gas Reporter - December 2011 - 37
American Oil & Gas Reporter - December 2011 - Shale Gas Subcommittee
American Oil & Gas Reporter - December 2011 - 39
American Oil & Gas Reporter - December 2011 - Endangered Species
American Oil & Gas Reporter - December 2011 - 41
American Oil & Gas Reporter - December 2011 - Midstream Startups Emerging to Meet Booming Demand
American Oil & Gas Reporter - December 2011 - 43
American Oil & Gas Reporter - December 2011 - 44
American Oil & Gas Reporter - December 2011 - 45
American Oil & Gas Reporter - December 2011 - 46
American Oil & Gas Reporter - December 2011 - 47
American Oil & Gas Reporter - December 2011 - 48
American Oil & Gas Reporter - December 2011 - 49
American Oil & Gas Reporter - December 2011 - 50
American Oil & Gas Reporter - December 2011 - 51
American Oil & Gas Reporter - December 2011 - 52
American Oil & Gas Reporter - December 2011 - 53
American Oil & Gas Reporter - December 2011 - 54
American Oil & Gas Reporter - December 2011 - 55
American Oil & Gas Reporter - December 2011 - 56
American Oil & Gas Reporter - December 2011 - 57
American Oil & Gas Reporter - December 2011 - Liquids Resource Plays Have Oil Production Rising Again
American Oil & Gas Reporter - December 2011 - 59
American Oil & Gas Reporter - December 2011 - 60
American Oil & Gas Reporter - December 2011 - 61
American Oil & Gas Reporter - December 2011 - 62
American Oil & Gas Reporter - December 2011 - 63
American Oil & Gas Reporter - December 2011 - 64
American Oil & Gas Reporter - December 2011 - 65
American Oil & Gas Reporter - December 2011 - 66
American Oil & Gas Reporter - December 2011 - 67
American Oil & Gas Reporter - December 2011 - 68
American Oil & Gas Reporter - December 2011 - 69
American Oil & Gas Reporter - December 2011 - 70
American Oil & Gas Reporter - December 2011 - 71
American Oil & Gas Reporter - December 2011 - 72
American Oil & Gas Reporter - December 2011 - Organizers Anticipating Big Things for 2012 PBIOS
American Oil & Gas Reporter - December 2011 - Cover Story
American Oil & Gas Reporter - December 2011 - 75
American Oil & Gas Reporter - December 2011 - 76
American Oil & Gas Reporter - December 2011 - 77
American Oil & Gas Reporter - December 2011 - 78
American Oil & Gas Reporter - December 2011 - 79
American Oil & Gas Reporter - December 2011 - 80
American Oil & Gas Reporter - December 2011 - 81
American Oil & Gas Reporter - December 2011 - 82
American Oil & Gas Reporter - December 2011 - R&D Areas Key to Improving Fracturing
American Oil & Gas Reporter - December 2011 - 84
American Oil & Gas Reporter - December 2011 - 85
American Oil & Gas Reporter - December 2011 - 86
American Oil & Gas Reporter - December 2011 - 87
American Oil & Gas Reporter - December 2011 - 88
American Oil & Gas Reporter - December 2011 - 89
American Oil & Gas Reporter - December 2011 - 90
American Oil & Gas Reporter - December 2011 - Natural Gas Offers Solutions as Transportation Fuel
American Oil & Gas Reporter - December 2011 - 92
American Oil & Gas Reporter - December 2011 - 93
American Oil & Gas Reporter - December 2011 - 94
American Oil & Gas Reporter - December 2011 - 95
American Oil & Gas Reporter - December 2011 - Completion Design, Frac Modeling Optimize Eagle Ford Wells
American Oil & Gas Reporter - December 2011 - 97
American Oil & Gas Reporter - December 2011 - 98
American Oil & Gas Reporter - December 2011 - 99
American Oil & Gas Reporter - December 2011 - 100
American Oil & Gas Reporter - December 2011 - 101
American Oil & Gas Reporter - December 2011 - 102
American Oil & Gas Reporter - December 2011 - 103
American Oil & Gas Reporter - December 2011 - 104
American Oil & Gas Reporter - December 2011 - 105
American Oil & Gas Reporter - December 2011 - 106
American Oil & Gas Reporter - December 2011 - 107
American Oil & Gas Reporter - December 2011 - 108
American Oil & Gas Reporter - December 2011 - 109
American Oil & Gas Reporter - December 2011 - 110
American Oil & Gas Reporter - December 2011 - Novel Drill-In Fluid Excels in Horizontal ERD Wells
American Oil & Gas Reporter - December 2011 - 112
American Oil & Gas Reporter - December 2011 - 113
American Oil & Gas Reporter - December 2011 - 114
American Oil & Gas Reporter - December 2011 - 115
American Oil & Gas Reporter - December 2011 - 116
American Oil & Gas Reporter - December 2011 - Technologies Optimize Sand Control
American Oil & Gas Reporter - December 2011 - 118
American Oil & Gas Reporter - December 2011 - 119
American Oil & Gas Reporter - December 2011 - 120
American Oil & Gas Reporter - December 2011 - 121
American Oil & Gas Reporter - December 2011 - Operators Must Manage Risk Before, During and After Drilling
American Oil & Gas Reporter - December 2011 - 123
American Oil & Gas Reporter - December 2011 - 124
American Oil & Gas Reporter - December 2011 - 125
American Oil & Gas Reporter - December 2011 - 126
American Oil & Gas Reporter - December 2011 - 127
American Oil & Gas Reporter - December 2011 - 128
American Oil & Gas Reporter - December 2011 - OCS Access: BOEM Offers Business-as-Usual OCS Leasing Plan
American Oil & Gas Reporter - December 2011 - Court Finds for Insurers in Gulf Spill Ruling
American Oil & Gas Reporter - December 2011 - 131
American Oil & Gas Reporter - December 2011 - 132
American Oil & Gas Reporter - December 2011 - OIPA
American Oil & Gas Reporter - December 2011 - 134
American Oil & Gas Reporter - December 2011 - 135
American Oil & Gas Reporter - December 2011 - Clean Air Act
American Oil & Gas Reporter - December 2011 - 137
American Oil & Gas Reporter - December 2011 - IOGA NY
American Oil & Gas Reporter - December 2011 - 139
American Oil & Gas Reporter - December 2011 - 140
American Oil & Gas Reporter - December 2011 - 141
American Oil & Gas Reporter - December 2011 - 142
American Oil & Gas Reporter - December 2011 - 143
American Oil & Gas Reporter - December 2011 - COGA
American Oil & Gas Reporter - December 2011 - 145
American Oil & Gas Reporter - December 2011 - 146
American Oil & Gas Reporter - December 2011 - IPAA Annual
American Oil & Gas Reporter - December 2011 - 148
American Oil & Gas Reporter - December 2011 - 149
American Oil & Gas Reporter - December 2011 - 150
American Oil & Gas Reporter - December 2011 - 151
American Oil & Gas Reporter - December 2011 - Louisiana
American Oil & Gas Reporter - December 2011 - 153
American Oil & Gas Reporter - December 2011 - 154
American Oil & Gas Reporter - December 2011 - 155
American Oil & Gas Reporter - December 2011 - West Virginia
American Oil & Gas Reporter - December 2011 - 157
American Oil & Gas Reporter - December 2011 - Pennsylvania
American Oil & Gas Reporter - December 2011 - Texas
American Oil & Gas Reporter - December 2011 - 160
American Oil & Gas Reporter - December 2011 - The American Well Servicing Directory, Winter 2011
American Oil & Gas Reporter - December 2011 - 162
American Oil & Gas Reporter - December 2011 - 163
American Oil & Gas Reporter - December 2011 - 164
American Oil & Gas Reporter - December 2011 - 165
American Oil & Gas Reporter - December 2011 - 166
American Oil & Gas Reporter - December 2011 - 167
American Oil & Gas Reporter - December 2011 - 168
American Oil & Gas Reporter - December 2011 - 169
American Oil & Gas Reporter - December 2011 - 170
American Oil & Gas Reporter - December 2011 - 171
American Oil & Gas Reporter - December 2011 - 172
American Oil & Gas Reporter - December 2011 - 173
American Oil & Gas Reporter - December 2011 - 174
American Oil & Gas Reporter - December 2011 - 175
American Oil & Gas Reporter - December 2011 - 176
American Oil & Gas Reporter - December 2011 - 177
American Oil & Gas Reporter - December 2011 - 178
American Oil & Gas Reporter - December 2011 - 179
American Oil & Gas Reporter - December 2011 - 180
American Oil & Gas Reporter - December 2011 - 181
American Oil & Gas Reporter - December 2011 - 182
American Oil & Gas Reporter - December 2011 - 183
American Oil & Gas Reporter - December 2011 - 184
American Oil & Gas Reporter - December 2011 - 185
American Oil & Gas Reporter - December 2011 - Industry Focus
American Oil & Gas Reporter - December 2011 - 187
American Oil & Gas Reporter - December 2011 - 188
American Oil & Gas Reporter - December 2011 - 189
American Oil & Gas Reporter - December 2011 - 190
American Oil & Gas Reporter - December 2011 - 191
American Oil & Gas Reporter - December 2011 - Classified Advertising
American Oil & Gas Reporter - December 2011 - 193
American Oil & Gas Reporter - December 2011 - Advertisers Index
American Oil & Gas Reporter - December 2011 - Cover3
American Oil & Gas Reporter - December 2011 - Cover4
http://www.nxtbook.com/nxtbooks/aogr/201909
http://www.nxtbook.com/nxtbooks/aogr/201908
http://www.nxtbook.com/nxtbooks/aogr/201907
http://www.nxtbook.com/nxtbooks/aogr/201906
http://www.nxtbook.com/nxtbooks/aogr/201905
http://www.nxtbook.com/nxtbooks/aogr/201904
http://www.nxtbook.com/nxtbooks/aogr/201903
http://www.nxtbook.com/nxtbooks/aogr/201902
http://www.nxtbook.com/nxtbooks/aogr/201901
http://www.nxtbook.com/nxtbooks/aogr/201812
http://www.nxtbook.com/nxtbooks/aogr/201811
http://www.nxtbook.com/nxtbooks/aogr/201810
http://www.nxtbook.com/nxtbooks/aogr/pbios_201810
http://www.nxtbook.com/nxtbooks/aogr/201809
http://www.nxtbook.com/nxtbooks/aogr/201808
http://www.nxtbook.com/nxtbooks/aogr/201807
http://www.nxtbook.com/nxtbooks/aogr/201806
http://www.nxtbook.com/nxtbooks/aogr/201805
http://www.nxtbook.com/nxtbooks/aogr/201804
http://www.nxtbook.com/nxtbooks/aogr/201803
http://www.nxtbook.com/nxtbooks/aogr/201802
http://www.nxtbook.com/nxtbooks/aogr/201801
http://www.nxtbook.com/nxtbooks/aogr/201712
http://www.nxtbook.com/nxtbooks/aogr/201711
http://www.nxtbook.com/nxtbooks/aogr/201710
http://www.nxtbook.com/nxtbooks/aogr/201709
http://www.nxtbook.com/nxtbooks/aogr/201708
http://www.nxtbook.com/nxtbooks/aogr/201707
http://www.nxtbook.com/nxtbooks/aogr/201706
http://www.nxtbook.com/nxtbooks/aogr/201705
http://www.nxtbook.com/nxtbooks/aogr/201704
http://www.nxtbook.com/nxtbooks/aogr/201703
http://www.nxtbook.com/nxtbooks/aogr/201702
http://www.nxtbook.com/nxtbooks/aogr/201701
http://www.nxtbook.com/nxtbooks/aogr/201612
http://www.nxtbook.com/nxtbooks/aogr/201611
http://www.nxtbook.com/nxtbooks/aogr/201610
http://www.nxtbook.com/nxtbooks/aogr/pbios2016_programguide
http://www.nxtbook.com/nxtbooks/aogr/201609
http://www.nxtbook.com/nxtbooks/aogr/201608
http://www.nxtbook.com/nxtbooks/aogr/201607
http://www.nxtbook.com/nxtbooks/aogr/201606
http://www.nxtbook.com/nxtbooks/aogr/201605
http://www.nxtbook.com/nxtbooks/aogr/201604
http://www.nxtbook.com/nxtbooks/aogr/201603
http://www.nxtbook.com/nxtbooks/aogr/201602
http://www.nxtbook.com/nxtbooks/aogr/201601
http://www.nxtbook.com/nxtbooks/aogr/201512
http://www.nxtbook.com/nxtbooks/aogr/201511
http://www.nxtbook.com/nxtbooks/aogr/201510
http://www.nxtbook.com/nxtbooks/aogr/201509
http://www.nxtbook.com/nxtbooks/aogr/201508
http://www.nxtbook.com/nxtbooks/aogr/201507
http://www.nxtbook.com/nxtbooks/aogr/201506
http://www.nxtbook.com/nxtbooks/aogr/201505
http://www.nxtbook.com/nxtbooks/aogr/201504
http://www.nxtbook.com/nxtbooks/aogr/201503
http://www.nxtbook.com/nxtbooks/aogr/201502
http://www.nxtbook.com/nxtbooks/aogr/201501
http://www.nxtbook.com/nxtbooks/aogr/201412
http://www.nxtbook.com/nxtbooks/aogr/201411
http://www.nxtbook.com/nxtbooks/aogr/201410
http://www.nxtbook.com/nxtbooks/aogr/201409
http://www.nxtbook.com/nxtbooks/aogr/pbios2014_programguide
http://www.nxtbook.com/nxtbooks/aogr/201408
http://www.nxtbook.com/nxtbooks/aogr/201407
http://www.nxtbook.com/nxtbooks/aogr/201406
http://www.nxtbook.com/nxtbooks/aogr/201405
http://www.nxtbook.com/nxtbooks/aogr/201404
http://www.nxtbook.com/nxtbooks/aogr/201403
http://www.nxtbook.com/nxtbooks/aogr/201402
http://www.nxtbook.com/nxtbooks/aogr/201401
http://www.nxtbook.com/nxtbooks/aogr/201312
http://www.nxtbook.com/nxtbooks/aogr/201311
http://www.nxtbook.com/nxtbooks/aogr/201310
http://www.nxtbook.com/nxtbooks/aogr/201309
http://www.nxtbook.com/nxtbooks/aogr/201308
http://www.nxtbook.com/nxtbooks/aogr/201307
http://www.nxtbook.com/nxtbooks/aogr/201306
http://www.nxtbook.com/nxtbooks/aogr/201305
http://www.nxtbook.com/nxtbooks/aogr/201304
http://www.nxtbook.com/nxtbooks/aogr/201303
http://www.nxtbook.com/nxtbooks/aogr/201302
http://www.nxtbook.com/nxtbooks/aogr/201301
http://www.nxtbook.com/nxtbooks/aogr/201212
http://www.nxtbook.com/nxtbooks/aogr/201211
http://www.nxtbook.com/nxtbooks/aogr/201210
http://www.nxtbook.com/nxtbooks/aogr/201209
http://www.nxtbook.com/nxtbooks/aogr/2012_pbios
http://www.nxtbook.com/nxtbooks/aogr/201208
http://www.nxtbook.com/nxtbooks/aogr/201207
http://www.nxtbook.com/nxtbooks/aogr/201206
http://www.nxtbook.com/nxtbooks/aogr/201205
http://www.nxtbook.com/nxtbooks/aogr/201204
http://www.nxtbook.com/nxtbooks/aogr/201203
http://www.nxtbook.com/nxtbooks/aogr/201202
http://www.nxtbook.com/nxtbooks/aogr/201201
http://www.nxtbook.com/nxtbooks/demo/aogr_clone
http://www.nxtbook.com/nxtbooks/aogr/201112
http://www.nxtbookMEDIA.com