American Oil and Gas Reporter - September 2015 - 119

the nominal operating pressure of 200
psi to 380 psi as compressor stations fail
or go down," Easley relates. "It also has
seen temperatures ranging from -30 to
180 degrees Fahrenheit. After two years,
we have had no problems."
Easley attributes the pipe's success to
its toughness. "The nylon pipe has four
times the abrasion resistance of high-density
polyethylene, a common material in composite pipes, and two times the abrasion
resistance of steel," he reports. "That means
the outside is less likely to be damaged
when it is dragged across the ground during
installation, and the inside is less likely to
wear if the pipe transports sand-laden fluid
or other abrasive materials."
The pipe offers six times the impact
resistance of HDPE, Easley adds. "If the
pipe is where vehicles might run over it,
cows might step on it, or tools might
strike it, the improved impact resistance
can extend pipe life considerably," he
says.
To simplify installation, Easley says
the most popular pipe diameters are coiled
in continuous strands as long as 1,000
feet. "The strands are connected using
standard butt-fusion equipment," he notes.
"It is the same equipment used for HDPE,
so it is readily available, and there are a
lot of experienced crews that can learn

Raptor™ nylon pipe from INVISTA combines low installation and maintenance costs with
the durability to withstand temperature and pressure fluctuations, INVISTA reports.

how to install the pipe in only a few
hours."
Once installed, the pipe has low maintenance costs, Easley adds. "It resists
corrosion naturally, so the operator does
not need to install or maintain a cathodic
protection system," he points out.
"Because it has lower thermal conductivity than steel and HDPE, paraffin
is less likely to build up," he continues.
"Also, the surface is smoother than steel,
which further reduces paraffin buildup,
resulting in less need for cleaning."
Moreover, Easley says the pipe's installed cost averages 30-60 percent that
of steel. "The cost savings compared

with other spoolable composites vary
widely, but we might save 30 percent,"
he remarks.
Although the pipe generally has a
long-term pressure rating of 350-400 psi,
Easley says it can endure as much as 900
psi for short periods, and tolerate temperatures to 200 degrees F long enough
to accommodate hot oiling. "The pipe
was engineered to have abrasion and impact resistance, chemical tolerance, and
the toughness to endure pressure and
temperature spikes so operators have the
peace of mind that comes with knowing
it can deal with the unexpected," he concludes.
❒

SEPTEMBER 2015 119


http://www.aogr.com

American Oil and Gas Reporter - September 2015

Table of Contents for the Digital Edition of American Oil and Gas Reporter - September 2015

Contents
American Oil and Gas Reporter - September 2015 - Cover1
American Oil and Gas Reporter - September 2015 - Cover2
American Oil and Gas Reporter - September 2015 - 3
American Oil and Gas Reporter - September 2015 - 4
American Oil and Gas Reporter - September 2015 - Contents
American Oil and Gas Reporter - September 2015 - 6
American Oil and Gas Reporter - September 2015 - 7
American Oil and Gas Reporter - September 2015 - 8
American Oil and Gas Reporter - September 2015 - 9
American Oil and Gas Reporter - September 2015 - 10
American Oil and Gas Reporter - September 2015 - 11
American Oil and Gas Reporter - September 2015 - 12
American Oil and Gas Reporter - September 2015 - 13
American Oil and Gas Reporter - September 2015 - 14
American Oil and Gas Reporter - September 2015 - 15
American Oil and Gas Reporter - September 2015 - 16
American Oil and Gas Reporter - September 2015 - 17
American Oil and Gas Reporter - September 2015 - 18
American Oil and Gas Reporter - September 2015 - 19
American Oil and Gas Reporter - September 2015 - 20
American Oil and Gas Reporter - September 2015 - 21
American Oil and Gas Reporter - September 2015 - 22
American Oil and Gas Reporter - September 2015 - 23
American Oil and Gas Reporter - September 2015 - 24
American Oil and Gas Reporter - September 2015 - 25
American Oil and Gas Reporter - September 2015 - 26
American Oil and Gas Reporter - September 2015 - 27
American Oil and Gas Reporter - September 2015 - 28
American Oil and Gas Reporter - September 2015 - 29
American Oil and Gas Reporter - September 2015 - 30
American Oil and Gas Reporter - September 2015 - 31
American Oil and Gas Reporter - September 2015 - 32
American Oil and Gas Reporter - September 2015 - 33
American Oil and Gas Reporter - September 2015 - 34
American Oil and Gas Reporter - September 2015 - 35
American Oil and Gas Reporter - September 2015 - 36
American Oil and Gas Reporter - September 2015 - 37
American Oil and Gas Reporter - September 2015 - 38
American Oil and Gas Reporter - September 2015 - 39
American Oil and Gas Reporter - September 2015 - 40
American Oil and Gas Reporter - September 2015 - 41
American Oil and Gas Reporter - September 2015 - 42
American Oil and Gas Reporter - September 2015 - 43
American Oil and Gas Reporter - September 2015 - 44
American Oil and Gas Reporter - September 2015 - 45
American Oil and Gas Reporter - September 2015 - 46
American Oil and Gas Reporter - September 2015 - 47
American Oil and Gas Reporter - September 2015 - 48
American Oil and Gas Reporter - September 2015 - 49
American Oil and Gas Reporter - September 2015 - 50
American Oil and Gas Reporter - September 2015 - 51
American Oil and Gas Reporter - September 2015 - 52
American Oil and Gas Reporter - September 2015 - 53
American Oil and Gas Reporter - September 2015 - 54
American Oil and Gas Reporter - September 2015 - 55
American Oil and Gas Reporter - September 2015 - 56
American Oil and Gas Reporter - September 2015 - 57
American Oil and Gas Reporter - September 2015 - 58
American Oil and Gas Reporter - September 2015 - 59
American Oil and Gas Reporter - September 2015 - 60
American Oil and Gas Reporter - September 2015 - 61
American Oil and Gas Reporter - September 2015 - 62
American Oil and Gas Reporter - September 2015 - 63
American Oil and Gas Reporter - September 2015 - 64
American Oil and Gas Reporter - September 2015 - 65
American Oil and Gas Reporter - September 2015 - 66
American Oil and Gas Reporter - September 2015 - 67
American Oil and Gas Reporter - September 2015 - 68
American Oil and Gas Reporter - September 2015 - 69
American Oil and Gas Reporter - September 2015 - 70
American Oil and Gas Reporter - September 2015 - 71
American Oil and Gas Reporter - September 2015 - 72
American Oil and Gas Reporter - September 2015 - 73
American Oil and Gas Reporter - September 2015 - 74
American Oil and Gas Reporter - September 2015 - 75
American Oil and Gas Reporter - September 2015 - 76
American Oil and Gas Reporter - September 2015 - 77
American Oil and Gas Reporter - September 2015 - 78
American Oil and Gas Reporter - September 2015 - 79
American Oil and Gas Reporter - September 2015 - 80
American Oil and Gas Reporter - September 2015 - 81
American Oil and Gas Reporter - September 2015 - 82
American Oil and Gas Reporter - September 2015 - 83
American Oil and Gas Reporter - September 2015 - 84
American Oil and Gas Reporter - September 2015 - 85
American Oil and Gas Reporter - September 2015 - 86
American Oil and Gas Reporter - September 2015 - 87
American Oil and Gas Reporter - September 2015 - 88
American Oil and Gas Reporter - September 2015 - 89
American Oil and Gas Reporter - September 2015 - 90
American Oil and Gas Reporter - September 2015 - 91
American Oil and Gas Reporter - September 2015 - 92
American Oil and Gas Reporter - September 2015 - 93
American Oil and Gas Reporter - September 2015 - 94
American Oil and Gas Reporter - September 2015 - 95
American Oil and Gas Reporter - September 2015 - 96
American Oil and Gas Reporter - September 2015 - 97
American Oil and Gas Reporter - September 2015 - 98
American Oil and Gas Reporter - September 2015 - 99
American Oil and Gas Reporter - September 2015 - 100
American Oil and Gas Reporter - September 2015 - 101
American Oil and Gas Reporter - September 2015 - 102
American Oil and Gas Reporter - September 2015 - 103
American Oil and Gas Reporter - September 2015 - 104
American Oil and Gas Reporter - September 2015 - 105
American Oil and Gas Reporter - September 2015 - 106
American Oil and Gas Reporter - September 2015 - 107
American Oil and Gas Reporter - September 2015 - 108
American Oil and Gas Reporter - September 2015 - 109
American Oil and Gas Reporter - September 2015 - 110
American Oil and Gas Reporter - September 2015 - 111
American Oil and Gas Reporter - September 2015 - 112
American Oil and Gas Reporter - September 2015 - 113
American Oil and Gas Reporter - September 2015 - 114
American Oil and Gas Reporter - September 2015 - 115
American Oil and Gas Reporter - September 2015 - 116
American Oil and Gas Reporter - September 2015 - 117
American Oil and Gas Reporter - September 2015 - 118
American Oil and Gas Reporter - September 2015 - 119
American Oil and Gas Reporter - September 2015 - 120
American Oil and Gas Reporter - September 2015 - 121
American Oil and Gas Reporter - September 2015 - 122
American Oil and Gas Reporter - September 2015 - 123
American Oil and Gas Reporter - September 2015 - 124
American Oil and Gas Reporter - September 2015 - 125
American Oil and Gas Reporter - September 2015 - 126
American Oil and Gas Reporter - September 2015 - 127
American Oil and Gas Reporter - September 2015 - 128
American Oil and Gas Reporter - September 2015 - 129
American Oil and Gas Reporter - September 2015 - 130
American Oil and Gas Reporter - September 2015 - 131
American Oil and Gas Reporter - September 2015 - 132
American Oil and Gas Reporter - September 2015 - 133
American Oil and Gas Reporter - September 2015 - 134
American Oil and Gas Reporter - September 2015 - 135
American Oil and Gas Reporter - September 2015 - 136
American Oil and Gas Reporter - September 2015 - 137
American Oil and Gas Reporter - September 2015 - 138
American Oil and Gas Reporter - September 2015 - 139
American Oil and Gas Reporter - September 2015 - 140
American Oil and Gas Reporter - September 2015 - 141
American Oil and Gas Reporter - September 2015 - 142
American Oil and Gas Reporter - September 2015 - 143
American Oil and Gas Reporter - September 2015 - 144
American Oil and Gas Reporter - September 2015 - 145
American Oil and Gas Reporter - September 2015 - 146
American Oil and Gas Reporter - September 2015 - 147
American Oil and Gas Reporter - September 2015 - 148
American Oil and Gas Reporter - September 2015 - 149
American Oil and Gas Reporter - September 2015 - 150
American Oil and Gas Reporter - September 2015 - 151
American Oil and Gas Reporter - September 2015 - 152
American Oil and Gas Reporter - September 2015 - 153
American Oil and Gas Reporter - September 2015 - 154
American Oil and Gas Reporter - September 2015 - 155
American Oil and Gas Reporter - September 2015 - 156
American Oil and Gas Reporter - September 2015 - 157
American Oil and Gas Reporter - September 2015 - 158
American Oil and Gas Reporter - September 2015 - 159
American Oil and Gas Reporter - September 2015 - 160
American Oil and Gas Reporter - September 2015 - 161
American Oil and Gas Reporter - September 2015 - 162
American Oil and Gas Reporter - September 2015 - 163
American Oil and Gas Reporter - September 2015 - 164
American Oil and Gas Reporter - September 2015 - 165
American Oil and Gas Reporter - September 2015 - 166
American Oil and Gas Reporter - September 2015 - 167
American Oil and Gas Reporter - September 2015 - 168
American Oil and Gas Reporter - September 2015 - 169
American Oil and Gas Reporter - September 2015 - 170
American Oil and Gas Reporter - September 2015 - 171
American Oil and Gas Reporter - September 2015 - 172
American Oil and Gas Reporter - September 2015 - 173
American Oil and Gas Reporter - September 2015 - 174
American Oil and Gas Reporter - September 2015 - 175
American Oil and Gas Reporter - September 2015 - 176
American Oil and Gas Reporter - September 2015 - 177
American Oil and Gas Reporter - September 2015 - 178
American Oil and Gas Reporter - September 2015 - Cover3
American Oil and Gas Reporter - September 2015 - Cover4
https://www.nxtbook.com/nxtbooks/aogr/202403
https://www.nxtbook.com/nxtbooks/aogr/202402
https://www.nxtbook.com/nxtbooks/aogr/202401
https://www.nxtbook.com/nxtbooks/aogr/202312
https://www.nxtbook.com/nxtbooks/aogr/202311
https://www.nxtbook.com/nxtbooks/aogr/pbios_202310
https://www.nxtbook.com/nxtbooks/aogr/202309
https://www.nxtbook.com/nxtbooks/aogr/202308
https://www.nxtbook.com/nxtbooks/aogr/202307
https://www.nxtbook.com/nxtbooks/aogr/202306
https://www.nxtbook.com/nxtbooks/aogr/202305
https://www.nxtbook.com/nxtbooks/aogr/202304
https://www.nxtbook.com/nxtbooks/aogr/202303
https://www.nxtbook.com/nxtbooks/aogr/202302
https://www.nxtbook.com/nxtbooks/aogr/202301
https://www.nxtbook.com/nxtbooks/aogr/202212
https://www.nxtbook.com/nxtbooks/aogr/202211
https://www.nxtbook.com/nxtbooks/aogr/202210
https://www.nxtbook.com/nxtbooks/aogr/202209
https://www.nxtbook.com/nxtbooks/aogr/202208
https://www.nxtbook.com/nxtbooks/aogr/202207
https://www.nxtbook.com/nxtbooks/aogr/202206
https://www.nxtbook.com/nxtbooks/aogr/202205
https://www.nxtbook.com/nxtbooks/aogr/202204
https://www.nxtbook.com/nxtbooks/aogr/202203
https://www.nxtbook.com/nxtbooks/aogr/202202
https://www.nxtbook.com/nxtbooks/aogr/202201
https://www.nxtbook.com/nxtbooks/aogr/202112
https://www.nxtbook.com/nxtbooks/aogr/202111
https://www.nxtbook.com/nxtbooks/aogr/pbios_202110
https://www.nxtbook.com/nxtbooks/aogr/202109
https://www.nxtbook.com/nxtbooks/aogr/202108
https://www.nxtbook.com/nxtbooks/aogr/202107
https://www.nxtbook.com/nxtbooks/aogr/202106
https://www.nxtbook.com/nxtbooks/aogr/202105
https://www.nxtbook.com/nxtbooks/aogr/202104
https://www.nxtbook.com/nxtbooks/aogr/202103
https://www.nxtbook.com/nxtbooks/aogr/202102
https://www.nxtbook.com/nxtbooks/aogr/202101
https://www.nxtbook.com/nxtbooks/aogr/202012
https://www.nxtbook.com/nxtbooks/aogr/202011
https://www.nxtbook.com/nxtbooks/aogr/202010
https://www.nxtbook.com/nxtbooks/aogr/202009
https://www.nxtbook.com/nxtbooks/aogr/202008
https://www.nxtbook.com/nxtbooks/aogr/202007
https://www.nxtbook.com/nxtbooks/aogr/202006
https://www.nxtbook.com/nxtbooks/aogr/202005
https://www.nxtbook.com/nxtbooks/aogr/202004
https://www.nxtbook.com/nxtbooks/aogr/202003
https://www.nxtbook.com/nxtbooks/aogr/202002
https://www.nxtbook.com/nxtbooks/aogr/202001
https://www.nxtbook.com/nxtbooks/aogr/201912
https://www.nxtbook.com/nxtbooks/aogr/201911
https://www.nxtbook.com/nxtbooks/aogr/201910
https://www.nxtbook.com/nxtbooks/aogr/201909
https://www.nxtbook.com/nxtbooks/aogr/201908
https://www.nxtbook.com/nxtbooks/aogr/201907
https://www.nxtbook.com/nxtbooks/aogr/201906
https://www.nxtbook.com/nxtbooks/aogr/201905
https://www.nxtbook.com/nxtbooks/aogr/201904
https://www.nxtbook.com/nxtbooks/aogr/201903
https://www.nxtbook.com/nxtbooks/aogr/201902
https://www.nxtbook.com/nxtbooks/aogr/201901
https://www.nxtbook.com/nxtbooks/aogr/201812
https://www.nxtbook.com/nxtbooks/aogr/201811
https://www.nxtbook.com/nxtbooks/aogr/201810
https://www.nxtbook.com/nxtbooks/aogr/pbios_201810
https://www.nxtbook.com/nxtbooks/aogr/201809
https://www.nxtbook.com/nxtbooks/aogr/201808
https://www.nxtbook.com/nxtbooks/aogr/201807
https://www.nxtbook.com/nxtbooks/aogr/201806
https://www.nxtbook.com/nxtbooks/aogr/201805
https://www.nxtbook.com/nxtbooks/aogr/201804
https://www.nxtbook.com/nxtbooks/aogr/201803
https://www.nxtbook.com/nxtbooks/aogr/201802
https://www.nxtbook.com/nxtbooks/aogr/201801
https://www.nxtbook.com/nxtbooks/aogr/201712
https://www.nxtbook.com/nxtbooks/aogr/201711
https://www.nxtbook.com/nxtbooks/aogr/201710
https://www.nxtbook.com/nxtbooks/aogr/201709
https://www.nxtbook.com/nxtbooks/aogr/201708
https://www.nxtbook.com/nxtbooks/aogr/201707
https://www.nxtbook.com/nxtbooks/aogr/201706
https://www.nxtbook.com/nxtbooks/aogr/201705
https://www.nxtbook.com/nxtbooks/aogr/201704
https://www.nxtbook.com/nxtbooks/aogr/201703
https://www.nxtbook.com/nxtbooks/aogr/201702
https://www.nxtbook.com/nxtbooks/aogr/201701
https://www.nxtbook.com/nxtbooks/aogr/201612
https://www.nxtbook.com/nxtbooks/aogr/201611
https://www.nxtbook.com/nxtbooks/aogr/201610
https://www.nxtbook.com/nxtbooks/aogr/pbios2016_programguide
https://www.nxtbook.com/nxtbooks/aogr/201609
https://www.nxtbook.com/nxtbooks/aogr/201608
https://www.nxtbook.com/nxtbooks/aogr/201607
https://www.nxtbook.com/nxtbooks/aogr/201606
https://www.nxtbook.com/nxtbooks/aogr/201605
https://www.nxtbook.com/nxtbooks/aogr/201604
https://www.nxtbook.com/nxtbooks/aogr/201603
https://www.nxtbook.com/nxtbooks/aogr/201602
https://www.nxtbook.com/nxtbooks/aogr/201601
https://www.nxtbook.com/nxtbooks/aogr/201512
https://www.nxtbook.com/nxtbooks/aogr/201511
https://www.nxtbook.com/nxtbooks/aogr/201510
https://www.nxtbook.com/nxtbooks/aogr/201509
https://www.nxtbook.com/nxtbooks/aogr/201508
https://www.nxtbook.com/nxtbooks/aogr/201507
https://www.nxtbook.com/nxtbooks/aogr/201506
https://www.nxtbook.com/nxtbooks/aogr/201505
https://www.nxtbook.com/nxtbooks/aogr/201504
https://www.nxtbook.com/nxtbooks/aogr/201503
https://www.nxtbook.com/nxtbooks/aogr/201502
https://www.nxtbook.com/nxtbooks/aogr/201501
https://www.nxtbook.com/nxtbooks/aogr/201412
https://www.nxtbook.com/nxtbooks/aogr/201411
https://www.nxtbook.com/nxtbooks/aogr/201410
https://www.nxtbook.com/nxtbooks/aogr/201409
https://www.nxtbook.com/nxtbooks/aogr/pbios2014_programguide
https://www.nxtbook.com/nxtbooks/aogr/201408
https://www.nxtbook.com/nxtbooks/aogr/201407
https://www.nxtbook.com/nxtbooks/aogr/201406
https://www.nxtbook.com/nxtbooks/aogr/201405
https://www.nxtbook.com/nxtbooks/aogr/201404
https://www.nxtbook.com/nxtbooks/aogr/201403
https://www.nxtbook.com/nxtbooks/aogr/201402
https://www.nxtbook.com/nxtbooks/aogr/201401
https://www.nxtbook.com/nxtbooks/aogr/201312
https://www.nxtbook.com/nxtbooks/aogr/201311
https://www.nxtbook.com/nxtbooks/aogr/201310
https://www.nxtbook.com/nxtbooks/aogr/201309
https://www.nxtbook.com/nxtbooks/aogr/201308
https://www.nxtbook.com/nxtbooks/aogr/201307
https://www.nxtbook.com/nxtbooks/aogr/201306
https://www.nxtbook.com/nxtbooks/aogr/201305
https://www.nxtbook.com/nxtbooks/aogr/201304
https://www.nxtbook.com/nxtbooks/aogr/201303
https://www.nxtbook.com/nxtbooks/aogr/201302
https://www.nxtbook.com/nxtbooks/aogr/201301
https://www.nxtbook.com/nxtbooks/aogr/201212
https://www.nxtbook.com/nxtbooks/aogr/201211
https://www.nxtbook.com/nxtbooks/aogr/201210
https://www.nxtbook.com/nxtbooks/aogr/201209
https://www.nxtbook.com/nxtbooks/aogr/2012_pbios
https://www.nxtbook.com/nxtbooks/aogr/201208
https://www.nxtbook.com/nxtbooks/aogr/201207
https://www.nxtbook.com/nxtbooks/aogr/201206
https://www.nxtbook.com/nxtbooks/aogr/201205
https://www.nxtbook.com/nxtbooks/aogr/201204
https://www.nxtbook.com/nxtbooks/aogr/201203
https://www.nxtbook.com/nxtbooks/aogr/201202
https://www.nxtbook.com/nxtbooks/aogr/201201
https://www.nxtbook.com/nxtbooks/demo/aogr_clone
https://www.nxtbook.com/nxtbooks/aogr/201112
https://www.nxtbookmedia.com