ASHRAE Journal - September 2009 - 13

Case for, from Page 11 parisons to purposely oversized system selections. so, wHaT’s wrong with the article? • The math. • In any classically balanced static balance valve system, the hydraulically most significant path should have no “balancing” balance valve loss, as the pump is selected for that circuit. All other circuits’ balancing valves account for only the hydraulic differences of distribution piping and mixed head loss devices (coils, valves, etc.) required to make that circuit the same loss as the most significant. The other circuits’ balancing valves only account for the same pressure drop affiliated with piping in the most significant circuit. System curves don’t lie. • The article’s Figures 3 and 4 system curves are improperly calculated and shown for constant-speed pumping systems, and their referenced points of operation are improperly shown. • If required flow for the coils is 360 gpm, then the flow for the system is 360 gpm. • Why would an engineer care about the cost to run a purposely oversized system?—only, of course, if one is attempting to make an oversized system work as if it were properly sized. Balancing does not fix problems. It does adjust for variations in actual performance versus field performance if the associated equipment can be adjusted for if constraints such as the pump curve and control valve allow for it. • When comparing three-way versus two-way control, the authors state the branch losses to be 10 ft. That implies a very oversized valve and much hydraulic interaction between circuits that, without going into the control theory and relative mathematical proof, this would act in only a two-position control mode cycling the coil between full and no flow, wasting pump energy. Remember that in a modulating system with equal percentage control valve, stroking the valve from 100% open to 90% open ideally reduces flow by some 31%, and the next 10% of stroke September 2009 reduction reduces the flow to 48% of design flow. An experienced pump or control engineer would recognize that as being less than 12% of the design brake horsepower. And, better yet, most cooling load profiles would suggest that 97% of the yearly hours of operation would be at that point, a fact most system designers know. • The only trick in modulating a two-way, variable-speed, variable flow system is getting it to work as intended. In that regard, valve authority again plays an integral role in making the system work properly. While www.info.hotims.com/25208-25 ASHRAE Journal 13

ASHRAE Journal - September 2009

Table of Contents for the Digital Edition of ASHRAE Journal - September 2009

ASHRAE Journal - September 2009
Contents
Commentary
Industry News
Letters
Meetings and Shows
Getting to Net Zero
Feature Articles
How High Can You Go? Building Height and Net Zero
Lab for Learning
Solar Hot-Water Heating System: Lessons Learned
50th Anniversary—Low Pressure Steam Heating Systems
Building Sciences
Products
Emerging Technologies
People
Classified Advertising
Advertisers Index
ASHRAE Journal - September 2009 - ASHRAE Journal - September 2009
ASHRAE Journal - September 2009 - Cover2
ASHRAE Journal - September 2009 - 1
ASHRAE Journal - September 2009 - 2
ASHRAE Journal - September 2009 - Contents
ASHRAE Journal - September 2009 - 4
ASHRAE Journal - September 2009 - Commentary
ASHRAE Journal - September 2009 - Industry News
ASHRAE Journal - September 2009 - 7
ASHRAE Journal - September 2009 - 8
ASHRAE Journal - September 2009 - 9
ASHRAE Journal - September 2009 - Letters
ASHRAE Journal - September 2009 - 11
ASHRAE Journal - September 2009 - 12
ASHRAE Journal - September 2009 - 13
ASHRAE Journal - September 2009 - 14
ASHRAE Journal - September 2009 - 15
ASHRAE Journal - September 2009 - Meetings and Shows
ASHRAE Journal - September 2009 - 17
ASHRAE Journal - September 2009 - Feature Articles
ASHRAE Journal - September 2009 - 19
ASHRAE Journal - September 2009 - 20
ASHRAE Journal - September 2009 - 21
ASHRAE Journal - September 2009 - 22
ASHRAE Journal - September 2009 - 23
ASHRAE Journal - September 2009 - 24
ASHRAE Journal - September 2009 - 25
ASHRAE Journal - September 2009 - How High Can You Go? Building Height and Net Zero
ASHRAE Journal - September 2009 - 27
ASHRAE Journal - September 2009 - 28
ASHRAE Journal - September 2009 - 29
ASHRAE Journal - September 2009 - 30
ASHRAE Journal - September 2009 - 31
ASHRAE Journal - September 2009 - 32
ASHRAE Journal - September 2009 - 32a
ASHRAE Journal - September 2009 - 32b
ASHRAE Journal - September 2009 - 33
ASHRAE Journal - September 2009 - 34
ASHRAE Journal - September 2009 - 35
ASHRAE Journal - September 2009 - 36
ASHRAE Journal - September 2009 - 37
ASHRAE Journal - September 2009 - Lab for Learning
ASHRAE Journal - September 2009 - 39
ASHRAE Journal - September 2009 - 40
ASHRAE Journal - September 2009 - 41
ASHRAE Journal - September 2009 - 42
ASHRAE Journal - September 2009 - 43
ASHRAE Journal - September 2009 - Solar Hot-Water Heating System: Lessons Learned
ASHRAE Journal - September 2009 - 45
ASHRAE Journal - September 2009 - 46
ASHRAE Journal - September 2009 - 47
ASHRAE Journal - September 2009 - 48
ASHRAE Journal - September 2009 - 49
ASHRAE Journal - September 2009 - 50
ASHRAE Journal - September 2009 - 51
ASHRAE Journal - September 2009 - 52
ASHRAE Journal - September 2009 - 53
ASHRAE Journal - September 2009 - 50th Anniversary—Low Pressure Steam Heating Systems
ASHRAE Journal - September 2009 - 55
ASHRAE Journal - September 2009 - 56
ASHRAE Journal - September 2009 - 57
ASHRAE Journal - September 2009 - 58
ASHRAE Journal - September 2009 - 59
ASHRAE Journal - September 2009 - 60
ASHRAE Journal - September 2009 - 61
ASHRAE Journal - September 2009 - 62
ASHRAE Journal - September 2009 - 63
ASHRAE Journal - September 2009 - 64
ASHRAE Journal - September 2009 - 65
ASHRAE Journal - September 2009 - 66
ASHRAE Journal - September 2009 - 67
ASHRAE Journal - September 2009 - 68
ASHRAE Journal - September 2009 - 69
ASHRAE Journal - September 2009 - 70
ASHRAE Journal - September 2009 - 71
ASHRAE Journal - September 2009 - Building Sciences
ASHRAE Journal - September 2009 - 73
ASHRAE Journal - September 2009 - 74
ASHRAE Journal - September 2009 - 75
ASHRAE Journal - September 2009 - 76
ASHRAE Journal - September 2009 - 77
ASHRAE Journal - September 2009 - 78
ASHRAE Journal - September 2009 - 79
ASHRAE Journal - September 2009 - 80
ASHRAE Journal - September 2009 - 81
ASHRAE Journal - September 2009 - Products
ASHRAE Journal - September 2009 - 83
ASHRAE Journal - September 2009 - Emerging Technologies
ASHRAE Journal - September 2009 - 85
ASHRAE Journal - September 2009 - 86
ASHRAE Journal - September 2009 - 87
ASHRAE Journal - September 2009 - 88
ASHRAE Journal - September 2009 - 89
ASHRAE Journal - September 2009 - People
ASHRAE Journal - September 2009 - 91
ASHRAE Journal - September 2009 - 92
ASHRAE Journal - September 2009 - Classified Advertising
ASHRAE Journal - September 2009 - 94
ASHRAE Journal - September 2009 - 95
ASHRAE Journal - September 2009 - Advertisers Index
ASHRAE Journal - September 2009 - Cover3
ASHRAE Journal - September 2009 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_ABEDGD
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com