ASHRAE Journal - September 2009 - 49

We found the dc pump manufacturer had a model with a different body style that provided 1.5 times more flow at the pump curve point where we had been operating (Figure 5). We purchased and installed the new pump and a strainer with additional isolation valves for easy future removal. The glycol flow jumped from 1.6 to 2.0 gpm (0.10 to 0.13 L/s) with the new pump. We suspect that the system simply air locked because we didn’t have enough flow with the thicker glycol at lower winter temperatures before the sun heated the panels. We installed a pressure transmitter at the same time so we could monitor glycol loop pressure. We tested the original, lower flow pump in a bucket and found it worked normally. We have not had an air locking problem due to insufficient flow since. The PV panel was originally installed at the same sun angle as the thermal collectors. The gap we had allowed for snow removal proved to be insufficient. In January, the sun was shining brightly after a significant snowstorm, and we noticed a very low PV voltage, about 12V instead of 18, powering the pump, and the collector temperature was above 240°F (116°C). We rushed to the project to save the glycol that was boiling due to low flow. We found the snow had refrozen before sliding completely off the PV panel so the bottom solar cells were blocked (all the cells in a PV panel are in a series), preventing sufficient current output to power the pump. The thermal collectors had only melted away the top one-third of the snow cover but were sufficiently exposed to overheat and boil the glycol. We immediately cleared the PV panel, and the resultant flow cooled the temperature. Fortunately, we only had to recharge a small amount of missing glycol. We remounted the PV panel on stand-offs so that snow would slide completely off before the snow started melting on the thermal collectors. Upon questioning the maintenance staff, we found that they had been clearing away snow after storms, but hadn’t this time. We wanted to ensure that snow removal would happen naturally and not cause a problem again. In March 2009, we added a solar radiance sensor, so we could compare collector output with actual solar availability, to gain experience with collector efficiency in our geographic area. The glycol pressure sensor was wired in so we could monitor system pressure. We added a dc current sensor to the PV-powered pump, so we could learn how it performs versus its pump curve. The peak flow ran at 1.5 gpm (0.09 L/s) instead of the 2.0 gpm (0.3 L/s) we had last fall, we suspected either the strainer needed cleaning, or there was some other problem. In April 2009 we noticed that the collector inlet temperature was much higher at night and during the day than had been the case previously. It often exceeded the collector outlet temperature, while the solar tanks were gaining in temperature during daytime C www.info.hotims.com/25208-49 www.info.hotims.com/25208-5 September 2009 ASHRAE Journal 49

ASHRAE Journal - September 2009

Table of Contents for the Digital Edition of ASHRAE Journal - September 2009

ASHRAE Journal - September 2009
Contents
Commentary
Industry News
Letters
Meetings and Shows
Getting to Net Zero
Feature Articles
How High Can You Go? Building Height and Net Zero
Lab for Learning
Solar Hot-Water Heating System: Lessons Learned
50th Anniversary—Low Pressure Steam Heating Systems
Building Sciences
Products
Emerging Technologies
People
Classified Advertising
Advertisers Index
ASHRAE Journal - September 2009 - ASHRAE Journal - September 2009
ASHRAE Journal - September 2009 - Cover2
ASHRAE Journal - September 2009 - 1
ASHRAE Journal - September 2009 - 2
ASHRAE Journal - September 2009 - Contents
ASHRAE Journal - September 2009 - 4
ASHRAE Journal - September 2009 - Commentary
ASHRAE Journal - September 2009 - Industry News
ASHRAE Journal - September 2009 - 7
ASHRAE Journal - September 2009 - 8
ASHRAE Journal - September 2009 - 9
ASHRAE Journal - September 2009 - Letters
ASHRAE Journal - September 2009 - 11
ASHRAE Journal - September 2009 - 12
ASHRAE Journal - September 2009 - 13
ASHRAE Journal - September 2009 - 14
ASHRAE Journal - September 2009 - 15
ASHRAE Journal - September 2009 - Meetings and Shows
ASHRAE Journal - September 2009 - 17
ASHRAE Journal - September 2009 - Feature Articles
ASHRAE Journal - September 2009 - 19
ASHRAE Journal - September 2009 - 20
ASHRAE Journal - September 2009 - 21
ASHRAE Journal - September 2009 - 22
ASHRAE Journal - September 2009 - 23
ASHRAE Journal - September 2009 - 24
ASHRAE Journal - September 2009 - 25
ASHRAE Journal - September 2009 - How High Can You Go? Building Height and Net Zero
ASHRAE Journal - September 2009 - 27
ASHRAE Journal - September 2009 - 28
ASHRAE Journal - September 2009 - 29
ASHRAE Journal - September 2009 - 30
ASHRAE Journal - September 2009 - 31
ASHRAE Journal - September 2009 - 32
ASHRAE Journal - September 2009 - 32a
ASHRAE Journal - September 2009 - 32b
ASHRAE Journal - September 2009 - 33
ASHRAE Journal - September 2009 - 34
ASHRAE Journal - September 2009 - 35
ASHRAE Journal - September 2009 - 36
ASHRAE Journal - September 2009 - 37
ASHRAE Journal - September 2009 - Lab for Learning
ASHRAE Journal - September 2009 - 39
ASHRAE Journal - September 2009 - 40
ASHRAE Journal - September 2009 - 41
ASHRAE Journal - September 2009 - 42
ASHRAE Journal - September 2009 - 43
ASHRAE Journal - September 2009 - Solar Hot-Water Heating System: Lessons Learned
ASHRAE Journal - September 2009 - 45
ASHRAE Journal - September 2009 - 46
ASHRAE Journal - September 2009 - 47
ASHRAE Journal - September 2009 - 48
ASHRAE Journal - September 2009 - 49
ASHRAE Journal - September 2009 - 50
ASHRAE Journal - September 2009 - 51
ASHRAE Journal - September 2009 - 52
ASHRAE Journal - September 2009 - 53
ASHRAE Journal - September 2009 - 50th Anniversary—Low Pressure Steam Heating Systems
ASHRAE Journal - September 2009 - 55
ASHRAE Journal - September 2009 - 56
ASHRAE Journal - September 2009 - 57
ASHRAE Journal - September 2009 - 58
ASHRAE Journal - September 2009 - 59
ASHRAE Journal - September 2009 - 60
ASHRAE Journal - September 2009 - 61
ASHRAE Journal - September 2009 - 62
ASHRAE Journal - September 2009 - 63
ASHRAE Journal - September 2009 - 64
ASHRAE Journal - September 2009 - 65
ASHRAE Journal - September 2009 - 66
ASHRAE Journal - September 2009 - 67
ASHRAE Journal - September 2009 - 68
ASHRAE Journal - September 2009 - 69
ASHRAE Journal - September 2009 - 70
ASHRAE Journal - September 2009 - 71
ASHRAE Journal - September 2009 - Building Sciences
ASHRAE Journal - September 2009 - 73
ASHRAE Journal - September 2009 - 74
ASHRAE Journal - September 2009 - 75
ASHRAE Journal - September 2009 - 76
ASHRAE Journal - September 2009 - 77
ASHRAE Journal - September 2009 - 78
ASHRAE Journal - September 2009 - 79
ASHRAE Journal - September 2009 - 80
ASHRAE Journal - September 2009 - 81
ASHRAE Journal - September 2009 - Products
ASHRAE Journal - September 2009 - 83
ASHRAE Journal - September 2009 - Emerging Technologies
ASHRAE Journal - September 2009 - 85
ASHRAE Journal - September 2009 - 86
ASHRAE Journal - September 2009 - 87
ASHRAE Journal - September 2009 - 88
ASHRAE Journal - September 2009 - 89
ASHRAE Journal - September 2009 - People
ASHRAE Journal - September 2009 - 91
ASHRAE Journal - September 2009 - 92
ASHRAE Journal - September 2009 - Classified Advertising
ASHRAE Journal - September 2009 - 94
ASHRAE Journal - September 2009 - 95
ASHRAE Journal - September 2009 - Advertisers Index
ASHRAE Journal - September 2009 - Cover3
ASHRAE Journal - September 2009 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_ABEDGD
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com