ASHRAE Journal - April 2010 - 65

TP TE TEpeak –10%

TP TE

TP1

Bad

Good TEpeak 10%

TP TE TE

Bad

Qmin

Qpeak

Qmax

Flow

Flow

Figure 1 (left): Selection range with no instability. Figure 2 (right): Selection range with possible instability.

The operating point(s) of the fan must also be kept close to the peak efficiency point if the power consumed is to be kept to minimum values. Unfortunately, past practices often have been to use a small fan running at a higher speed due to cost pressures, both in the building and the fan. This usually means the fan is operated far to the right of peak efficiency. Figure 1 illustrates the portion of the fan curve where all operating points should be located. Unfortunately, not all fans have a continuously rising pressure curve at all flows between peak efficiency and peak efficiency less 10%. Figure 2 depicts such a case. Some (and probably most) fan types exhibit instability when operated in this region of positive slope in the pressure-volume curve. The method used to provide part-load performance is critical for any application where the system resistance varies significantly. The most commonly used method is adjustable frequency drives, which allow fan speed variation. The turndown available may be limited because the system resistance is not a constant orifice (i.e., the pressure varies as the flow is squared) since the VAV boxes require a minimum pressure to operate, and there is a minimum speed, which must be achieved to satisfy the boxes. Variable inlet vanes can also be used but there will be an efficiency penalty and turndown will be limited. Axial fans with variable geometry (blade angle change during rotation) are also available, and may be the solution of choice for systems with wide diversity (pressure does not follow flow squared). Retrofits present a more difficult problem than new construction since space may not be available to use fans of higher efficiency without major modifications. Although widespread agreement exists that energy use must be reduced, it is still unclear whether the architects, mechanical designers and building operators will make energy reduction the primary consideration in design, selection and operation. In this writer’s opinion, it may be
April	2010	

necessary for code authorities to take the lead in reducing energy use. John Murphy, Ph.D., is a principal of JOGRAM, Inc., in New Philadelphia, Ohio. He retired as engineering manager of Joy Technologies (formerly Joy Manufacturing) Fan Division.

www.info.hotims.com/30303-12

ASHRAE	Journal	

65



ASHRAE Journal - April 2010

Table of Contents for the Digital Edition of ASHRAE Journal - April 2010

ASHRAE Journal - April 2010
Contents
Commentary
Industry News
Letters
Meetings and Shows
Feature Articles
The Science of Evaporation is Key to Defense in Murder Trial
Selecting DOAS Equipment with Reserve Capacity
Technology Award Case Studies: Greening Hospitals
Technology Award Case Studies: Sustainable Remedy for Hospital
Building Sciences
Emerging Technologies
Technical Topics: Selecting Efficient Fans
Technical Topics: Dual-Capacity Heat Pumps
IAQ Applications
International Column
Classified Advertising
Advertisers Index
ASHRAE Journal - April 2010 - Intro
ASHRAE Journal - April 2010 - ASHRAE Journal - April 2010
ASHRAE Journal - April 2010 - Cover2
ASHRAE Journal - April 2010 - 1
ASHRAE Journal - April 2010 - 2
ASHRAE Journal - April 2010 - Contents
ASHRAE Journal - April 2010 - Commentary
ASHRAE Journal - April 2010 - 5
ASHRAE Journal - April 2010 - Industry News
ASHRAE Journal - April 2010 - 7
ASHRAE Journal - April 2010 - 8
ASHRAE Journal - April 2010 - 9
ASHRAE Journal - April 2010 - 10
ASHRAE Journal - April 2010 - 11
ASHRAE Journal - April 2010 - 12
ASHRAE Journal - April 2010 - 13
ASHRAE Journal - April 2010 - 14
ASHRAE Journal - April 2010 - 15
ASHRAE Journal - April 2010 - 16
ASHRAE Journal - April 2010 - 17
ASHRAE Journal - April 2010 - Letters
ASHRAE Journal - April 2010 - 19
ASHRAE Journal - April 2010 - Meetings and Shows
ASHRAE Journal - April 2010 - 21
ASHRAE Journal - April 2010 - The Science of Evaporation is Key to Defense in Murder Trial
ASHRAE Journal - April 2010 - 23
ASHRAE Journal - April 2010 - 24
ASHRAE Journal - April 2010 - 25
ASHRAE Journal - April 2010 - 26
ASHRAE Journal - April 2010 - 27
ASHRAE Journal - April 2010 - 28
ASHRAE Journal - April 2010 - 29
ASHRAE Journal - April 2010 - Selecting DOAS Equipment with Reserve Capacity
ASHRAE Journal - April 2010 - 31
ASHRAE Journal - April 2010 - 32
ASHRAE Journal - April 2010 - BRC1
ASHRAE Journal - April 2010 - BRC2
ASHRAE Journal - April 2010 - 33
ASHRAE Journal - April 2010 - 34
ASHRAE Journal - April 2010 - 35
ASHRAE Journal - April 2010 - 36
ASHRAE Journal - April 2010 - 37
ASHRAE Journal - April 2010 - 38
ASHRAE Journal - April 2010 - 39
ASHRAE Journal - April 2010 - 40
ASHRAE Journal - April 2010 - 41
ASHRAE Journal - April 2010 - Technology Award Case Studies: Greening Hospitals
ASHRAE Journal - April 2010 - 43
ASHRAE Journal - April 2010 - 44
ASHRAE Journal - April 2010 - 45
ASHRAE Journal - April 2010 - 46
ASHRAE Journal - April 2010 - 47
ASHRAE Journal - April 2010 - 48
ASHRAE Journal - April 2010 - 49
ASHRAE Journal - April 2010 - Technology Award Case Studies: Sustainable Remedy for Hospital
ASHRAE Journal - April 2010 - 51
ASHRAE Journal - April 2010 - 52
ASHRAE Journal - April 2010 - 53
ASHRAE Journal - April 2010 - Building Sciences
ASHRAE Journal - April 2010 - 55
ASHRAE Journal - April 2010 - 56
ASHRAE Journal - April 2010 - AP1
ASHRAE Journal - April 2010 - AP2
ASHRAE Journal - April 2010 - AP3
ASHRAE Journal - April 2010 - AP4
ASHRAE Journal - April 2010 - 57
ASHRAE Journal - April 2010 - 58
ASHRAE Journal - April 2010 - 59
ASHRAE Journal - April 2010 - Emerging Technologies
ASHRAE Journal - April 2010 - 61
ASHRAE Journal - April 2010 - 62
ASHRAE Journal - April 2010 - 63
ASHRAE Journal - April 2010 - Technical Topics: Selecting Efficient Fans
ASHRAE Journal - April 2010 - 65
ASHRAE Journal - April 2010 - Technical Topics: Dual-Capacity Heat Pumps
ASHRAE Journal - April 2010 - 67
ASHRAE Journal - April 2010 - 68
ASHRAE Journal - April 2010 - 69
ASHRAE Journal - April 2010 - IAQ Applications
ASHRAE Journal - April 2010 - 71
ASHRAE Journal - April 2010 - 72
ASHRAE Journal - April 2010 - 73
ASHRAE Journal - April 2010 - International Column
ASHRAE Journal - April 2010 - 75
ASHRAE Journal - April 2010 - 76
ASHRAE Journal - April 2010 - 77
ASHRAE Journal - April 2010 - 78
ASHRAE Journal - April 2010 - 79
ASHRAE Journal - April 2010 - 80
ASHRAE Journal - April 2010 - 81
ASHRAE Journal - April 2010 - 82
ASHRAE Journal - April 2010 - 83
ASHRAE Journal - April 2010 - 84
ASHRAE Journal - April 2010 - 85
ASHRAE Journal - April 2010 - Classified Advertising
ASHRAE Journal - April 2010 - 87
ASHRAE Journal - April 2010 - Advertisers Index
ASHRAE Journal - April 2010 - Cover3
ASHRAE Journal - April 2010 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_ABEDGD
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com