ASHRAE Journal - February 2011 - 74

emerging technologies	
temperature lift, and hence increased compressor COP, as shown in Figure 1. In this case, where 50% of the design capacity is needed, operating in on-off mode results in the condensing and evaporating temperatures being close to the level they would be if running continuously at full capacity. During the off cycle, the heat transfer capacity of the heat exchangers is unused. When running continuously at 50% of capacity, the difference between the condensing temperature and the outdoor temperature will be only half of the difference at full capacity, significantly raising the EER of the compressor. The evaporator temperature will be higher as well, even as the indoor airflow rate is reduced to maintain dehumidification capacity and to save blower power. Reduced	Blower	Power When the cooling capacity is reduced, the indoor airflow rate can be reduced as well, maintaining dehumidification capacity and reducing blower power by the cube of the flow rate. The May 2010 “Emerging Technologies” column discusses the relationship between blower speed, airflow rate and input power.3 Adding capacity modulation (capacity modulated compressor with a variable speed indoor air blower) to a given fixed capacity residential central air-conditioning system typically increases the SEER by 30% to 40%. The corresponding energy savings are 20% to 30%. Residential space cooling consumes
Condenser	(On-Off) 100 90 80 Temperature,	°F 70 60 50 40 30 Condenser	(Continuous	at	Half	Capacity)

Evaporator	(On-Off) 0	 0.5	

Evaporator	(Continuous	at	Half	Capacity) 1	 Time,	Hours 1.5	 2

Figure 1:	Continuous	vs.	on-off	operation	of	cooling	equipment. 2.48 quads of primary energy per year.4 Approximately 87% of this is consumed by central air-conditioning systems and heat pumps in cooling mode, with the balance consumed by room air conditioners.5 If all of the central air conditioners were replaced with high-SEER, capacity-modulated air conditioners, approximately 0.6 quads of primary energy would be saved annually.

market Factors

FLOWHOOD ELECTRONIC FLOWHOOD
DIRECT DIGITAL READOUT 25-2500 CFM

Sales of high-SEER, capacity modulated air conditioners are a small portion of residential central air conditioner sales and a negligible portion of room air conditioner sales in the U.S. The first-cost premium is the primary reason. The higher installed cost is due to the additional costs of the capacity modulated compressor, the variable speed indoor blower motor, and the more sophisticated control system needed to determine the correct capacity at any point in time. Faster payback will occur in warmer climates with longer cooling seasons and with heat pumps. However, in many of the warmer parts of the U.S., electric rates are lower than the national average.

references
1. 10 CFR Part 430, Subpart B, Appendix M, “Uniform Test Method for Measuring the Energy Consumption of Central Air Conditioners.” http://tinyurl.com/10CFR-B-M. 2. Dieckmann, J., et al. 2010. “VFDs for large chillers: large energy savings per installation.” ASHRAE Journal 52(6): 58 – 62. 3. Dieckmann, J., K. McKenney, and J. Brodrick. 2010. “Variable frequency drives, Part 2: VFDs for blowers.” ASHRAE Journal 52(5): 58 – 62. 4. DOE. 2010. Building Energy Data Book, Table 2.1.6: “Residential Energy End-Use Splits, by Fuel Type (Quadrillion Btu).” http://tinyurl. com/table216. 5. U.S. Department of Energy, Energy Information Administration, 2005 Residential Energy Consumption Survey. Table AC2: “Total Consumption for Air Conditioning by Equipment Type.” http://tinyurl. com/EIA-AC2.

AUTOMATICALLY CORRECTS FOR AIR DENSITY & BACKPRESSURE CHOICE OF METERS - AIR FLOW ONLY, OR AIR FLOW, VELOCITY, PRESSURE & TEMPERATURE OPTIONS INCLUDE: MEMORY, AVERAGE & SUM TO 2000 READINGS, SEQUENTIAL RECALL, AUTO-READ REPAIR POLICY - TWO WEEK TURNAROUND OR LESS CUSTOM TOPS MADE TO ORDER

Shortridge Instruments, Inc.
7855 East Redfield Road • Scottsdale, Arizona 85260 (480) 991-6744 FAX (480) 443-1267

www.info.hotims.com/33861-42

John Dieckmann is a director in the Mechanical Systems Group of TIAX LLC, Cambridge, Mass. James Brodrick, Ph.D., is a project manager with the Building Technologies Program, U.S. Department of Energy, Washington, D.C.
	 	 February	 2011

74	

ASHRAE	Journal	



ASHRAE Journal - February 2011

Table of Contents for the Digital Edition of ASHRAE Journal - February 2011

ASHRAE Journal - February 2011
Contents
Commentary
Industry News
Letters
Meetings and Shows
Feature Articles
Thermal Coupling of Cooling and Heating Systems
10 Common Problems in Energy Audits
Hall of Fame Feature: History of the Changing Concepts in Ventilation Requirements
A Guide to Wireless Technologies
Building Sciences
Solar NZEB Project
Emerging Technologies
People
Special Section
InfoCenter
Commissioning
Products
Washington Report
Classified Advertising
Advertisers Index
ASHRAE Journal - February 2011 - ASHRAE Journal - February 2011
ASHRAE Journal - February 2011 - Cover2
ASHRAE Journal - February 2011 - 1
ASHRAE Journal - February 2011 - 2
ASHRAE Journal - February 2011 - Contents
ASHRAE Journal - February 2011 - Commentary
ASHRAE Journal - February 2011 - 5
ASHRAE Journal - February 2011 - Industry News
ASHRAE Journal - February 2011 - 7
ASHRAE Journal - February 2011 - Letters
ASHRAE Journal - February 2011 - 9
ASHRAE Journal - February 2011 - 10
ASHRAE Journal - February 2011 - 11
ASHRAE Journal - February 2011 - 12
ASHRAE Journal - February 2011 - 13
ASHRAE Journal - February 2011 - 14
ASHRAE Journal - February 2011 - 15
ASHRAE Journal - February 2011 - Meetings and Shows
ASHRAE Journal - February 2011 - 17
ASHRAE Journal - February 2011 - Thermal Coupling of Cooling and Heating Systems
ASHRAE Journal - February 2011 - 19
ASHRAE Journal - February 2011 - 20
ASHRAE Journal - February 2011 - 21
ASHRAE Journal - February 2011 - 22
ASHRAE Journal - February 2011 - 23
ASHRAE Journal - February 2011 - 24
ASHRAE Journal - February 2011 - 25
ASHRAE Journal - February 2011 - 10 Common Problems in Energy Audits
ASHRAE Journal - February 2011 - 27
ASHRAE Journal - February 2011 - 28
ASHRAE Journal - February 2011 - 29
ASHRAE Journal - February 2011 - 30
ASHRAE Journal - February 2011 - 31
ASHRAE Journal - February 2011 - 32
ASHRAE Journal - February 2011 - 33
ASHRAE Journal - February 2011 - Hall of Fame Feature: History of the Changing Concepts in Ventilation Requirements
ASHRAE Journal - February 2011 - 35
ASHRAE Journal - February 2011 - 36
ASHRAE Journal - February 2011 - 37
ASHRAE Journal - February 2011 - 38
ASHRAE Journal - February 2011 - 39
ASHRAE Journal - February 2011 - 40
ASHRAE Journal - February 2011 - 41
ASHRAE Journal - February 2011 - 42
ASHRAE Journal - February 2011 - 43
ASHRAE Journal - February 2011 - A Guide to Wireless Technologies
ASHRAE Journal - February 2011 - 45
ASHRAE Journal - February 2011 - 46
ASHRAE Journal - February 2011 - 47
ASHRAE Journal - February 2011 - 48
ASHRAE Journal - February 2011 - 49
ASHRAE Journal - February 2011 - Building Sciences
ASHRAE Journal - February 2011 - 51
ASHRAE Journal - February 2011 - 52
ASHRAE Journal - February 2011 - 53
ASHRAE Journal - February 2011 - 54
ASHRAE Journal - February 2011 - 55
ASHRAE Journal - February 2011 - 56
ASHRAE Journal - February 2011 - 57
ASHRAE Journal - February 2011 - 58
ASHRAE Journal - February 2011 - 59
ASHRAE Journal - February 2011 - 60
ASHRAE Journal - February 2011 - 61
ASHRAE Journal - February 2011 - Solar NZEB Project
ASHRAE Journal - February 2011 - 63
ASHRAE Journal - February 2011 - 64
ASHRAE Journal - February 2011 - 65
ASHRAE Journal - February 2011 - 66
ASHRAE Journal - February 2011 - 67
ASHRAE Journal - February 2011 - 68
ASHRAE Journal - February 2011 - 69
ASHRAE Journal - February 2011 - Emerging Technologies
ASHRAE Journal - February 2011 - 71
ASHRAE Journal - February 2011 - 72
ASHRAE Journal - February 2011 - 73
ASHRAE Journal - February 2011 - 74
ASHRAE Journal - February 2011 - 75
ASHRAE Journal - February 2011 - People
ASHRAE Journal - February 2011 - 77
ASHRAE Journal - February 2011 - InfoCenter
ASHRAE Journal - February 2011 - 79
ASHRAE Journal - February 2011 - 80
ASHRAE Journal - February 2011 - 81
ASHRAE Journal - February 2011 - 82
ASHRAE Journal - February 2011 - 83
ASHRAE Journal - February 2011 - 84
ASHRAE Journal - February 2011 - 85
ASHRAE Journal - February 2011 - Commissioning
ASHRAE Journal - February 2011 - 87
ASHRAE Journal - February 2011 - 88
ASHRAE Journal - February 2011 - 89
ASHRAE Journal - February 2011 - 90
ASHRAE Journal - February 2011 - Products
ASHRAE Journal - February 2011 - Washington Report
ASHRAE Journal - February 2011 - Classified Advertising
ASHRAE Journal - February 2011 - 94
ASHRAE Journal - February 2011 - 95
ASHRAE Journal - February 2011 - Advertisers Index
ASHRAE Journal - February 2011 - Cover3
ASHRAE Journal - February 2011 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com