ASHRAE Journal - August 2011 - 26

“E

By Dave McFarlane, Member ASHRAE

Retrocommissioning Older Buildings
lectricity is penny cheap at NSP.” The slogan of Northern States Power (now Xcel Energy) of Minnesota and North Dakota encouraged
Not only were these systems inefficient, this was a period before personal computers were in use, so design calculations were done by hand. While this era was several years before my involvement in the HVAC industry, one can surmise that design airflows were estimated by the designer. We have seen older buildings with interior spaces sized for airflows of 1.5 to 2 cfm/ft2 (0.71 to 0.94 L/[s·m2]). Perimeter spaces were even higher. Control systems were usually pneumatic as HVAC direct digital controls
ashrae.org

consumption, not conservation, in the 1950s and 60s. Then, the Arab oil embargo in 1973 changed the way everyone thought about energy use, including the HVAC industry. This article deals with the buildings built when energy was cheap and fuel supplies seemed never-ending.

The following HVAC systems were in vogue in the 1960s through the 1980s: • Constant volume systems with hot water or electric reheat coils; • Constant volume systems with constant volume measuring boxes; • Dual duct hot deck/cold deck systems; • High static pressure systems; • Multizone constant volume systems; • Early variable air volume systems with pinch-off dampers and inlet vanes; and • Wild perimeter radiation or fin tube heating systems.
26 ASHRAE Journal

(DDC) only began being accepted in the mid-1980s. Because controls were pneumatic, sophisticated control sequences were difficult, if not impossible, to implement. Duct sealing was not common unless the system was designated as a high pressure system. A coating was applied to joints and seams to prevent leakage, but only on high pressure systems. Systems called “low pressure” were almost never sealed. We have measured, and industry literature supports, leakage rates in the 25% to 40% range for unsealed ducts. While SMACNA published the first duct sealing manual in 1984, it was not commonly accepted in many areas until 10 years later. About the Author
Dave McFarlane is president of Technical Commissioning, Fort Myers, Fla. He was a member of NEBB’s Commissioning Committee from 2000 – 2006 and chair from 2003 – 2004. He is an instructor for NEBB’s retrocommissioning and commissioning courses.

August 2011



ASHRAE Journal - August 2011

Table of Contents for the Digital Edition of ASHRAE Journal - August 2011

ASHRAE Journal - August 2011
Contents
Commentary
Industry News
Letters
Meetings and Shows
Feature Articles
2011–12 Presidential Address: Sustaining ASHRAE Through Leadership
Retrocommissioning Older Buildings
Liquid Refrigerant Pumping in Industrial Refrigeration Systems
Technology Award Case Studies:
Hospital Upgrade: Heat Recovery, Geothermal Save Energy
Cool Weather Savings: Using Hybrid Refrigeration Systems for Chiller Retrofit
Special Section
InfoCenter
Standing Columns
Solar NZEB Project
Emerging Technologies
Special Products
IAQ Applications
Washington Report
People
Products
Classified Advertising
Advertisers Index
ASHRAE Journal - August 2011 - Intro
ASHRAE Journal - August 2011 - ASHRAE Journal - August 2011
ASHRAE Journal - August 2011 - Cover2
ASHRAE Journal - August 2011 - 1
ASHRAE Journal - August 2011 - 2
ASHRAE Journal - August 2011 - Contents
ASHRAE Journal - August 2011 - Commentary
ASHRAE Journal - August 2011 - 5
ASHRAE Journal - August 2011 - Industry News
ASHRAE Journal - August 2011 - 7
ASHRAE Journal - August 2011 - 8
ASHRAE Journal - August 2011 - 9
ASHRAE Journal - August 2011 - Letters
ASHRAE Journal - August 2011 - 11
ASHRAE Journal - August 2011 - 12
ASHRAE Journal - August 2011 - 13
ASHRAE Journal - August 2011 - 14
ASHRAE Journal - August 2011 - 15
ASHRAE Journal - August 2011 - Meetings and Shows
ASHRAE Journal - August 2011 - 17
ASHRAE Journal - August 2011 - 2011–12 Presidential Address: Sustaining ASHRAE Through Leadership
ASHRAE Journal - August 2011 - 19
ASHRAE Journal - August 2011 - 20
ASHRAE Journal - August 2011 - 21
ASHRAE Journal - August 2011 - 22
ASHRAE Journal - August 2011 - 23
ASHRAE Journal - August 2011 - 24
ASHRAE Journal - August 2011 - 25
ASHRAE Journal - August 2011 - Retrocommissioning Older Buildings
ASHRAE Journal - August 2011 - 27
ASHRAE Journal - August 2011 - 28
ASHRAE Journal - August 2011 - 29
ASHRAE Journal - August 2011 - 30
ASHRAE Journal - August 2011 - 31
ASHRAE Journal - August 2011 - 32
ASHRAE Journal - August 2011 - 33
ASHRAE Journal - August 2011 - 34
ASHRAE Journal - August 2011 - 35
ASHRAE Journal - August 2011 - Liquid Refrigerant Pumping in Industrial Refrigeration Systems
ASHRAE Journal - August 2011 - 37
ASHRAE Journal - August 2011 - 38
ASHRAE Journal - August 2011 - 39
ASHRAE Journal - August 2011 - 40
ASHRAE Journal - August 2011 - 41
ASHRAE Journal - August 2011 - 42
ASHRAE Journal - August 2011 - 43
ASHRAE Journal - August 2011 - Hospital Upgrade: Heat Recovery, Geothermal Save Energy
ASHRAE Journal - August 2011 - 45
ASHRAE Journal - August 2011 - 46
ASHRAE Journal - August 2011 - 47
ASHRAE Journal - August 2011 - Cool Weather Savings: Using Hybrid Refrigeration Systems for Chiller Retrofit
ASHRAE Journal - August 2011 - 49
ASHRAE Journal - August 2011 - 50
ASHRAE Journal - August 2011 - 51
ASHRAE Journal - August 2011 - InfoCenter
ASHRAE Journal - August 2011 - 53
ASHRAE Journal - August 2011 - 54
ASHRAE Journal - August 2011 - 55
ASHRAE Journal - August 2011 - 56
ASHRAE Journal - August 2011 - 57
ASHRAE Journal - August 2011 - 58
ASHRAE Journal - August 2011 - 59
ASHRAE Journal - August 2011 - 60
ASHRAE Journal - August 2011 - Solar NZEB Project
ASHRAE Journal - August 2011 - 62
ASHRAE Journal - August 2011 - 63
ASHRAE Journal - August 2011 - 64
ASHRAE Journal - August 2011 - 65
ASHRAE Journal - August 2011 - Emerging Technologies
ASHRAE Journal - August 2011 - 67
ASHRAE Journal - August 2011 - 68
ASHRAE Journal - August 2011 - 69
ASHRAE Journal - August 2011 - 70
ASHRAE Journal - August 2011 - 71
ASHRAE Journal - August 2011 - 72
ASHRAE Journal - August 2011 - 73
ASHRAE Journal - August 2011 - 74
ASHRAE Journal - August 2011 - Special Products
ASHRAE Journal - August 2011 - IAQ Applications
ASHRAE Journal - August 2011 - 77
ASHRAE Journal - August 2011 - 78
ASHRAE Journal - August 2011 - 79
ASHRAE Journal - August 2011 - Washington Report
ASHRAE Journal - August 2011 - 81
ASHRAE Journal - August 2011 - People
ASHRAE Journal - August 2011 - 83
ASHRAE Journal - August 2011 - Products
ASHRAE Journal - August 2011 - 85
ASHRAE Journal - August 2011 - Classified Advertising
ASHRAE Journal - August 2011 - 87
ASHRAE Journal - August 2011 - Advertisers Index
ASHRAE Journal - August 2011 - Cover3
ASHRAE Journal - August 2011 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com