ASHRAE Journal - August 2011 - 43

in an ammonia liquid line requires a pressure difference of approximately 15 psi (103 kPa) just to lift liquid to the roof. Hydrostatic Lock-Up. Hydrostatic lock-up is the trapping of subcooled (or pressurized) liquid refrigerant in a fixed volume and exposing that trapped volume to a heat source. As the trapped liquid absorbs heat, it causes an increase in temperature, which causes the trapped liquid to volumetrically expand leading to a substantial increase in refrigerant pressure and an increased likelihood of component or equipment failure. It is important to identify locations within a refrigeration system that can trap liquid and provide suitable means of overpressure protection. ASHRAE Standard 15-2010, Safety Standard for Refrigerating Systems, provides requirements for protection from hydrostatic lock-up. The liquid feed valve train on an overfed evaporator is a location where hydrostatic lock-up is only a danger during maintenance procedures; therefore, can be effectively managed with proper procedures and employee training. However, the liquid supply piping between the pump discharge check valve and the liquid feed solenoids on the evaporators must be protected from hydrostatic lock-up in the event of a plant-wide power failure. No amount of procedures or training can mitigate this hydraulic lock-up scenario; therefore, the installation of a hydrostatic relief device downstream of the pump discharge check valve piped back to the recirculator vessel is required.

Summary
This article introduced concepts that are distinctive to pumping refrigerants with centrifugal pumps. In industrial refrigeration systems, the use of centrifugal pumps for supplying low temperature liquid refrigerant to loads has become quite common. Although a simple concept, the successful design, installation, and operation of centrifugal liquid refrigerant pumps does require care and attention to a number of details. One of the most common operational problems fought in the field is refrigerant pump cavitation. In a number of installations, we have found the contributing or root cause to cavitation is the excess flow of liquid through the pump due to hand-expansion valves on individual evaporators being set too far open. When cavitation occurs, cooling capacity is lost and the likelihood of premature pump (or motor) failure increases. We hope this article helps you understand and troubleshoot potential problems that may exist in refrigerant pumping systems.

References
1. 2010 ASHRAE Handbook—Refrigeration. 2. Stoecker, W.F. 1998. Industrial Refrigeration Handbook. McGraw Hill Publishers. 3. Chaurette, J. 2011. Personal communication.

www.info.hotims.com/37989-41

www.info.hotims.com/37989-24

August 2011

ASHRAE Journal

43



ASHRAE Journal - August 2011

Table of Contents for the Digital Edition of ASHRAE Journal - August 2011

ASHRAE Journal - August 2011
Contents
Commentary
Industry News
Letters
Meetings and Shows
Feature Articles
2011–12 Presidential Address: Sustaining ASHRAE Through Leadership
Retrocommissioning Older Buildings
Liquid Refrigerant Pumping in Industrial Refrigeration Systems
Technology Award Case Studies:
Hospital Upgrade: Heat Recovery, Geothermal Save Energy
Cool Weather Savings: Using Hybrid Refrigeration Systems for Chiller Retrofit
Special Section
InfoCenter
Standing Columns
Solar NZEB Project
Emerging Technologies
Special Products
IAQ Applications
Washington Report
People
Products
Classified Advertising
Advertisers Index
ASHRAE Journal - August 2011 - Intro
ASHRAE Journal - August 2011 - ASHRAE Journal - August 2011
ASHRAE Journal - August 2011 - Cover2
ASHRAE Journal - August 2011 - 1
ASHRAE Journal - August 2011 - 2
ASHRAE Journal - August 2011 - Contents
ASHRAE Journal - August 2011 - Commentary
ASHRAE Journal - August 2011 - 5
ASHRAE Journal - August 2011 - Industry News
ASHRAE Journal - August 2011 - 7
ASHRAE Journal - August 2011 - 8
ASHRAE Journal - August 2011 - 9
ASHRAE Journal - August 2011 - Letters
ASHRAE Journal - August 2011 - 11
ASHRAE Journal - August 2011 - 12
ASHRAE Journal - August 2011 - 13
ASHRAE Journal - August 2011 - 14
ASHRAE Journal - August 2011 - 15
ASHRAE Journal - August 2011 - Meetings and Shows
ASHRAE Journal - August 2011 - 17
ASHRAE Journal - August 2011 - 2011–12 Presidential Address: Sustaining ASHRAE Through Leadership
ASHRAE Journal - August 2011 - 19
ASHRAE Journal - August 2011 - 20
ASHRAE Journal - August 2011 - 21
ASHRAE Journal - August 2011 - 22
ASHRAE Journal - August 2011 - 23
ASHRAE Journal - August 2011 - 24
ASHRAE Journal - August 2011 - 25
ASHRAE Journal - August 2011 - Retrocommissioning Older Buildings
ASHRAE Journal - August 2011 - 27
ASHRAE Journal - August 2011 - 28
ASHRAE Journal - August 2011 - 29
ASHRAE Journal - August 2011 - 30
ASHRAE Journal - August 2011 - 31
ASHRAE Journal - August 2011 - 32
ASHRAE Journal - August 2011 - 33
ASHRAE Journal - August 2011 - 34
ASHRAE Journal - August 2011 - 35
ASHRAE Journal - August 2011 - Liquid Refrigerant Pumping in Industrial Refrigeration Systems
ASHRAE Journal - August 2011 - 37
ASHRAE Journal - August 2011 - 38
ASHRAE Journal - August 2011 - 39
ASHRAE Journal - August 2011 - 40
ASHRAE Journal - August 2011 - 41
ASHRAE Journal - August 2011 - 42
ASHRAE Journal - August 2011 - 43
ASHRAE Journal - August 2011 - Hospital Upgrade: Heat Recovery, Geothermal Save Energy
ASHRAE Journal - August 2011 - 45
ASHRAE Journal - August 2011 - 46
ASHRAE Journal - August 2011 - 47
ASHRAE Journal - August 2011 - Cool Weather Savings: Using Hybrid Refrigeration Systems for Chiller Retrofit
ASHRAE Journal - August 2011 - 49
ASHRAE Journal - August 2011 - 50
ASHRAE Journal - August 2011 - 51
ASHRAE Journal - August 2011 - InfoCenter
ASHRAE Journal - August 2011 - 53
ASHRAE Journal - August 2011 - 54
ASHRAE Journal - August 2011 - 55
ASHRAE Journal - August 2011 - 56
ASHRAE Journal - August 2011 - 57
ASHRAE Journal - August 2011 - 58
ASHRAE Journal - August 2011 - 59
ASHRAE Journal - August 2011 - 60
ASHRAE Journal - August 2011 - Solar NZEB Project
ASHRAE Journal - August 2011 - 62
ASHRAE Journal - August 2011 - 63
ASHRAE Journal - August 2011 - 64
ASHRAE Journal - August 2011 - 65
ASHRAE Journal - August 2011 - Emerging Technologies
ASHRAE Journal - August 2011 - 67
ASHRAE Journal - August 2011 - 68
ASHRAE Journal - August 2011 - 69
ASHRAE Journal - August 2011 - 70
ASHRAE Journal - August 2011 - 71
ASHRAE Journal - August 2011 - 72
ASHRAE Journal - August 2011 - 73
ASHRAE Journal - August 2011 - 74
ASHRAE Journal - August 2011 - Special Products
ASHRAE Journal - August 2011 - IAQ Applications
ASHRAE Journal - August 2011 - 77
ASHRAE Journal - August 2011 - 78
ASHRAE Journal - August 2011 - 79
ASHRAE Journal - August 2011 - Washington Report
ASHRAE Journal - August 2011 - 81
ASHRAE Journal - August 2011 - People
ASHRAE Journal - August 2011 - 83
ASHRAE Journal - August 2011 - Products
ASHRAE Journal - August 2011 - 85
ASHRAE Journal - August 2011 - Classified Advertising
ASHRAE Journal - August 2011 - 87
ASHRAE Journal - August 2011 - Advertisers Index
ASHRAE Journal - August 2011 - Cover3
ASHRAE Journal - August 2011 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_KTUZMA
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_ABEDGD
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com