ASHRAE Journal - April 2013 - 26

Figure 1: Fan efficiency grade curves for FEG50 – FEG90.
Source: AMCA 205-12 Energy Efficiency Classification for Fans.
to have FEG ratings for fans certified by AMCA’s Certified
Ratings Program.
To streamline the application of AMCA 205, AMCA developed FEG curves with discrete bands based on fan size (impeller diameter) and fan peak total efficiency (Figure 1). The
fan efficiency bands came about by collecting fan efficiency
data on a variety of fan types and sizes from manufacturers
around the world. The efficiencies were plotted and the bands
were developed from the data.
The shape of the discrete bands helps accommodate an entire fan product line with the same FEG rating. As defined by
AMCA 205, a fan belongs to a FEG if, for the fan impeller
diameter, the fan peak efficiency falls between the upper and
lower limits for that grade.
Not only is high peak efficiency important, so is selection
of the fan to operate near peak efficiency. AMCA 205 states
that the “fan operating efficiency at all intended operating
point(s) shall not be less than 15 percentage points below
the fan peak total efficiency” (Figure 2). AMCA encourages codes and standards bodies adopting AMCA 205 to
include a selection window of this type in their fan efficiency requirement. Standard 90.1 has a selection window
of 15 percentage points; the IgCC has a more restrictive 10
percentage points.

U.S. Fan Efficiency Codes and Standards
When fan efficiency requirements were first considered
in 2007, the initial concept was to set a requirement at a
single efficiency threshold, i.e., 65%. However, setting a
simple efficiency threshold would eliminate many fans
based on fan diameter (Figure 3). This is what drove the
development of a fan efficiency classification system (i.e.,
FEGs) that could be used in codes and standards for energy
and construction.
As mentioned previously, reducing fan energy consumption
must go beyond the fan peak efficiency, hence, a complete fan
efficiency requirement within a code or standard will have at
least two clauses: one that establishes a baseline fan efficiency
26	

ASHRAE Journal	

Figure 2: Allowable selection range based on operation within
15 percentage points of the peak total efficiency.

Figure 3: FEG curves in comparison with a straight-line single
efficiency requirement. Regulating fans based on simple efficiency would eliminate many types based on fan size. For
example, an efficiency based on 65% would eliminate many
fans under 20 in. (508 mm) in diameter.
grade, and another that specifies a selection window relative to
the fan’s peak total efficiency.
As shown in the sidebar, the fan efficiency requirement in
Standard 90.1-2013 has these two parts: one sets the efficiency requirement at FEG67 based on AMCA 205; the other requires the sizing/selection window to be within 15 percentage
points of the peak fan total efficiency.
The 2012 International Green Construction Code, in a section that pertains only to buildings 25,000 ft2 (2323 m2) and
less, being a “green” standard has more stringent requirements: a higher FEG level, FEG71, and a smaller selection
window of 10 percentage points.
Beyond setting a FEG and selection window, codes and
standards adopting AMCA 205 need to specify scope, such as
a s h r a e . o r g 		

April 2013



ASHRAE Journal - April 2013

Table of Contents for the Digital Edition of ASHRAE Journal - April 2013

ASHRAE Journal - April 2013
Contents
Commentary
Industry News
Letters
Meetings and Shows
Feature Articles
Ground-Coupled Heat Pump and Energy Storage
Fan Efficiency Requirements for Standard 90.1-2013
Technology Award Case Studies:
Geothermal for 5 Ecosystems
Holistic HVAC Design
Standing Columns
Engineer’s Notebook
Data Centers
Emerging Technologies
IAQ Applications
Refrigeration Applications
Special Products
People
International Column
Energy Modeling
Products
Classified Advertising
Advertisers Index
ASHRAE Journal - April 2013 - ASHRAE Journal - April 2013
ASHRAE Journal - April 2013 - Cover2
ASHRAE Journal - April 2013 - 1
ASHRAE Journal - April 2013 - 2
ASHRAE Journal - April 2013 - Contents
ASHRAE Journal - April 2013 - Commentary
ASHRAE Journal - April 2013 - 5
ASHRAE Journal - April 2013 - Industry News
ASHRAE Journal - April 2013 - 7
ASHRAE Journal - April 2013 - 8
ASHRAE Journal - April 2013 - Letters
ASHRAE Journal - April 2013 - Meetings and Shows
ASHRAE Journal - April 2013 - 11
ASHRAE Journal - April 2013 - 12
ASHRAE Journal - April 2013 - 13
ASHRAE Journal - April 2013 - Ground-Coupled Heat Pump and Energy Storage
ASHRAE Journal - April 2013 - 15
ASHRAE Journal - April 2013 - 16
ASHRAE Journal - April 2013 - I1
ASHRAE Journal - April 2013 - I2
ASHRAE Journal - April 2013 - I3
ASHRAE Journal - April 2013 - I4
ASHRAE Journal - April 2013 - 17
ASHRAE Journal - April 2013 - 18
ASHRAE Journal - April 2013 - 19
ASHRAE Journal - April 2013 - 20
ASHRAE Journal - April 2013 - 21
ASHRAE Journal - April 2013 - 22
ASHRAE Journal - April 2013 - 23
ASHRAE Journal - April 2013 - Fan Efficiency Requirements for Standard 90.1-2013
ASHRAE Journal - April 2013 - 25
ASHRAE Journal - April 2013 - 26
ASHRAE Journal - April 2013 - 27
ASHRAE Journal - April 2013 - 28
ASHRAE Journal - April 2013 - 29
ASHRAE Journal - April 2013 - 30
ASHRAE Journal - April 2013 - 31
ASHRAE Journal - April 2013 - Geothermal for 5 Ecosystems
ASHRAE Journal - April 2013 - 33
ASHRAE Journal - April 2013 - 34
ASHRAE Journal - April 2013 - 35
ASHRAE Journal - April 2013 - 36
ASHRAE Journal - April 2013 - 37
ASHRAE Journal - April 2013 - 38
ASHRAE Journal - April 2013 - 39
ASHRAE Journal - April 2013 - Holistic HVAC Design
ASHRAE Journal - April 2013 - 41
ASHRAE Journal - April 2013 - 42
ASHRAE Journal - April 2013 - 43
ASHRAE Journal - April 2013 - 44
ASHRAE Journal - April 2013 - 45
ASHRAE Journal - April 2013 - 46
ASHRAE Journal - April 2013 - 47
ASHRAE Journal - April 2013 - Engineer’s Notebook
ASHRAE Journal - April 2013 - 49
ASHRAE Journal - April 2013 - 50
ASHRAE Journal - April 2013 - 51
ASHRAE Journal - April 2013 - 52
ASHRAE Journal - April 2013 - 53
ASHRAE Journal - April 2013 - Data Centers
ASHRAE Journal - April 2013 - 55
ASHRAE Journal - April 2013 - 56
ASHRAE Journal - April 2013 - 57
ASHRAE Journal - April 2013 - 58
ASHRAE Journal - April 2013 - 59
ASHRAE Journal - April 2013 - Emerging Technologies
ASHRAE Journal - April 2013 - 61
ASHRAE Journal - April 2013 - 62
ASHRAE Journal - April 2013 - 63
ASHRAE Journal - April 2013 - IAQ Applications
ASHRAE Journal - April 2013 - 65
ASHRAE Journal - April 2013 - 66
ASHRAE Journal - April 2013 - Refrigeration Applications
ASHRAE Journal - April 2013 - Special Products
ASHRAE Journal - April 2013 - People
ASHRAE Journal - April 2013 - International Column
ASHRAE Journal - April 2013 - 71
ASHRAE Journal - April 2013 - Energy Modeling
ASHRAE Journal - April 2013 - 73
ASHRAE Journal - April 2013 - Products
ASHRAE Journal - April 2013 - 75
ASHRAE Journal - April 2013 - 76
ASHRAE Journal - April 2013 - 77
ASHRAE Journal - April 2013 - 78
ASHRAE Journal - April 2013 - Classified Advertising
ASHRAE Journal - April 2013 - Advertisers Index
ASHRAE Journal - April 2013 - Cover3
ASHRAE Journal - April 2013 - Cover4
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_ABEDGD
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201910
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201909
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019septmeber_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2019september
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201908
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201907
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201906
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201905
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201904
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019april
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201903
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2019march
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201902
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201901
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_showguide2019
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018december
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018november
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2018fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_2018october
http://www.nxtbook.com/nxtbooks/ashrae/ashraemexico_2018
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201810
http://www.nxtbook.com/nxtbooks/ashrae/ashraeinsights_201806
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201805
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201804
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201803
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201712
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201711
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201710
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2017fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201709
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201705
http://www.nxtbook.com/nxtbooks/ashrae/ashrae_meetinginsert_201610
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2016fall
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acrexindia
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_amca_2015summer
http://www.nxtbook.com/nxtbooks/amca/2014summer2
http://www.nxtbook.com/nxtbooks/amca/2014summer
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acma_2014summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201311
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201309
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_acmasupp_2013fall
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201305
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201303
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2013winter
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201211
http://www.nxtbook.com/nxtbooks/ashrae/achr_expo_mexico2012
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201209
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v3
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201208_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201205
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201203
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2012winter
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201111_v2
http://www.nxtbook.com/nxtbooks/ashrae/ashraejournal_201109_v2
http://www.nxtbook.com/nxtbooks/ashrae/pubcatalog_2011summer
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201105
http://www.nxtbook.com/nxtbooks/ashrae/meetingplanner_201103
http://www.nxtbookMEDIA.com