Subiesport Magazine - June/July 2008 - (Page 62) 2007 LEGACY GT PROJECT 73. Stock vs. ported. Make sure you block off the holes in the sides of the TGV with pipe plugs. You can also weld them shut if you are maniacal. 74. Another quick item, we installed larger injectors, a must for a big turbo build. These are Deatschwerks 750cc nozzles. 75. It is now time to reinstall your turbo. Re-install the turbo coolant and oil lines now as well. Then, reinstall the intake manifold. 76. Our new clutch assembly. This is a heavy-duty unit for the newer Legacy GT, from Advanced Clutch Technology. Their catalog didn’t list it at the time of press, but it’s available. 77. Torque your flywheel bolts to 54lbs and your clutch cover bolts to 15lbs. That’s it! Your engine is built and ready to drop back in. Reassembly is the reverse of disassembly. PROJECT SOURCES PDX TUNING Installation and Sales Phone: 503-624-2919 Online: www.pdxtuning.com COSWORTH Forged Pistons Phone: 310-534-1390 Online: www.cosworth.com GROUP A PERFORMANCE Pulley Kit Phone: 416-628-3559 Online: www.groupa.ca 62 JULY 2008 Make sure that before you start your engine, you fill it with regular non-synthetic, non-detergent oil and crank the motor over a few times with the coil packs disconnected (a remote starter will work here too) to build up oil pressure and circulate oil in the engine. Starting the engine dry will result in instantaneous failure. Once the engine starts, listen for any excessive noise like piston slap or valve/ piston interference. Also, let the engine go through a complete warm-up cycle and burp the coolant system of air before driving the car. Give your car a good 500 miles of easy break-in, keeping revs below 4,000rpm, and using only light boost to seat the rings and break in bearings. Some say that the oil should be changed after the first 100 miles, again with basic 10w30 non-synthetic oil. Then change it again after 500 miles with whatever oil you intend to use for there on out. A proper synthetic is best. After that, your new engine should be ready for a tune or track use, and, if properly built, should give you miles and miles of hard-driving performance. DEATSCHWERKS 750cc Top-Feed Injectors Phone: 405-415-6862 Online: www.deatschwerks.com ADVANCED CLUTCH TECHNOLOGY Clutch Kit (#SB5-HDMM), Flywheel (#600480) Phone: 661-940-7555 Online: www.advancedclutch.com http://slowboyracing.com http://www.pdxtuning.com http://www.deatschwerks.com http://www.cosworth.com http://slowboyracing.com http://www.advancedclutch.com http://www.groupa.ca
Table of Contents Feed for the Digital Edition of Subiesport Magazine - June/July 2008 Subiesport Magazine - June/July 2008 Contents Editor Letters Readers’ Rides Subaru News Fresh Squeezed Hell's Legacy Under the Radar Project GT Rebuild New Engine AVO 420 Turbo Perrin Intercooler Rally Like a Rockstar Rally Jordan Adventure WRC Rally Argentina WRC Rally Jordan WRC Rally d’Italia Sardegna Where to buy Subiesport WRC2008 Debut Rally America: Olympus Ad Directory Rally America: Oregon Trail Spotted! Subiesport Magazine - June/July 2008 Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page Cover1) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page Cover2) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 1) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 2) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 3) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 4) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 5) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 6) Subiesport Magazine - June/July 2008 - Subiesport Magazine - June/July 2008 (Page 7) Subiesport Magazine - June/July 2008 - Contents (Page 8) Subiesport Magazine - June/July 2008 - Contents (Page 9) Subiesport Magazine - June/July 2008 - Contents (Page 10) Subiesport Magazine - June/July 2008 - Contents (Page 11) Subiesport Magazine - June/July 2008 - Editor (Page 12) Subiesport Magazine - June/July 2008 - Editor (Page 13) Subiesport Magazine - June/July 2008 - Letters (Page 14) Subiesport Magazine - June/July 2008 - Letters (Page 15) Subiesport Magazine - June/July 2008 - Readers’ Rides (Page 16) Subiesport Magazine - June/July 2008 - Readers’ Rides (Page 17) Subiesport Magazine - June/July 2008 - Subaru News (Page 18) Subiesport Magazine - June/July 2008 - Subaru News (Page 19) Subiesport Magazine - June/July 2008 - Subaru News (Page 20) Subiesport Magazine - June/July 2008 - Subaru News (Page 21) Subiesport Magazine - June/July 2008 - Subaru News (Page 22) Subiesport Magazine - June/July 2008 - Subaru News (Page 23) Subiesport Magazine - June/July 2008 - Subaru News (Page 24) Subiesport Magazine - June/July 2008 - Subaru News (Page 25) Subiesport Magazine - June/July 2008 - Subaru News (Page 26) Subiesport Magazine - June/July 2008 - Subaru News (Page 27) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 28) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 29) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 30) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 31) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 32) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 33) Subiesport Magazine - June/July 2008 - Fresh Squeezed (Page 34) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 35) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 36) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 37) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 38) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 39) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 40) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 41) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 42) Subiesport Magazine - June/July 2008 - Hell's Legacy (Page 43) Subiesport Magazine - June/July 2008 - Under the Radar (Page 44) Subiesport Magazine - June/July 2008 - Under the Radar (Page 45) Subiesport Magazine - June/July 2008 - Under the Radar (Page 46) Subiesport Magazine - June/July 2008 - Under the Radar (Page 47) Subiesport Magazine - June/July 2008 - Under the Radar (Page 48) Subiesport Magazine - June/July 2008 - Under the Radar (Page 49) Subiesport Magazine - June/July 2008 - New Engine (Page 50) Subiesport Magazine - June/July 2008 - New Engine (Page 51) Subiesport Magazine - June/July 2008 - New Engine (Page 52) Subiesport Magazine - June/July 2008 - New Engine (Page 53) Subiesport Magazine - June/July 2008 - New Engine (Page 54) Subiesport Magazine - June/July 2008 - New Engine (Page 55) Subiesport Magazine - June/July 2008 - New Engine (Page 56) Subiesport Magazine - June/July 2008 - New Engine (Page 57) Subiesport Magazine - June/July 2008 - New Engine (Page 58) Subiesport Magazine - June/July 2008 - New Engine (Page 59) Subiesport Magazine - June/July 2008 - New Engine (Page 60) Subiesport Magazine - June/July 2008 - New Engine (Page 61) Subiesport Magazine - June/July 2008 - New Engine (Page 62) Subiesport Magazine - June/July 2008 - New Engine (Page 63) Subiesport Magazine - June/July 2008 - AVO 420 Turbo (Page 64) Subiesport Magazine - June/July 2008 - AVO 420 Turbo (Page 65) Subiesport Magazine - June/July 2008 - AVO 420 Turbo (Page 66) Subiesport Magazine - June/July 2008 - AVO 420 Turbo (Page 67) Subiesport Magazine - June/July 2008 - AVO 420 Turbo (Page 68) Subiesport Magazine - June/July 2008 - AVO 420 Turbo (Page 69) Subiesport Magazine - June/July 2008 - Perrin Intercooler (Page 70) Subiesport Magazine - June/July 2008 - Perrin Intercooler (Page 71) Subiesport Magazine - June/July 2008 - Perrin Intercooler (Page 72) Subiesport Magazine - June/July 2008 - Perrin Intercooler (Page 73) Subiesport Magazine - June/July 2008 - Perrin Intercooler (Page 74) Subiesport Magazine - June/July 2008 - Perrin Intercooler (Page 75) Subiesport Magazine - June/July 2008 - Rally Like a Rockstar (Page 76) Subiesport Magazine - June/July 2008 - Rally Like a Rockstar (Page 77) Subiesport Magazine - June/July 2008 - Rally Like a Rockstar (Page 78) Subiesport Magazine - June/July 2008 - Rally Like a Rockstar (Page 79) Subiesport Magazine - June/July 2008 - Rally Like a Rockstar (Page 80) Subiesport Magazine - June/July 2008 - Rally Like a Rockstar (Page 81) Subiesport Magazine - June/July 2008 - Rally Jordan Adventure (Page 82) Subiesport Magazine - June/July 2008 - Rally Jordan Adventure (Page 83) Subiesport Magazine - June/July 2008 - Rally Jordan Adventure (Page 84) Subiesport Magazine - June/July 2008 - Rally Jordan Adventure (Page 85) Subiesport Magazine - June/July 2008 - WRC Rally Argentina (Page 86) Subiesport Magazine - June/July 2008 - WRC Rally Argentina (Page 87) Subiesport Magazine - June/July 2008 - WRC Rally Jordan (Page 88) Subiesport Magazine - June/July 2008 - WRC Rally d’Italia Sardegna (Page 89) Subiesport Magazine - June/July 2008 - WRC Rally d’Italia Sardegna (Page 90) Subiesport Magazine - June/July 2008 - Where to buy Subiesport (Page 91) Subiesport Magazine - June/July 2008 - WRC2008 Debut (Page 92) Subiesport Magazine - June/July 2008 - Rally America: Olympus (Page 93) Subiesport Magazine - June/July 2008 - Rally America: Oregon Trail (Page 94) Subiesport Magazine - June/July 2008 - Rally America: Oregon Trail (Page 95) Subiesport Magazine - June/July 2008 - Spotted! (Page 96) Subiesport Magazine - June/July 2008 - Spotted! (Page Cover3) Subiesport Magazine - June/July 2008 - Spotted! (Page Cover4)
For optimal viewing of this digital publication, please enable JavaScript and then refresh the page. If you would like to try to load the digital publication without using Flash Player detection, please click here.