Waytek Catalog 227 - 107

Battery Management

Stock No. 80029

* Designed as a warning signal that the

* Disconnects predetermined loads from

the starting battery bank to ensure
sufficient power for starting
* Automatically reconnects loads if vehicle
is started or battery is recharged
* Start signal input override to prevent the
loads from disconnecting during starting
* Manual override for connecting or
disconnecting during emergencies
* Audible or visual alarm output activates
1 minute before disconnect
* 1 ⁄ 4" male tab contacts, 1 ⁄ 4" studs

Clamps & Clips

engine must be started to charge the
battery or turn off lights, entertainment,
communication equipment, etc., in use
* Trip point prompts an audible alarm
when the lights, flashers or any other
appliance has depleted the battery voltage
* When relay is open, the LED will flash;
closed in normal operation, the LED will
be off
* 1 ⁄ 4" male tab contacts

Terminals &
Connectors

Low Battery Switch

Stock No. 80028

loads from batteries to prevent excessive
discharge
* Reconnects loads if vehicle is started or
battery is recharged
* Prevents loads from disconnecting during
starting
* Manual override to connect or disconnect
during emergencies
* Available in adjustable or preset models
from 9 to 25 volts
* Audible or visual alarm 1 minute before
disconnect
* Maximum load current up to 300A
* Thermally protected
* Low standby current

Wire Coverings
& Protection

Low Battery Alarm

* Automatically disconnects non-critical

SAE
J1455

Wire &
Cable

LOW VOLTAGE DISCONNECTS

SAE
J1113

Tools

185°F (85°C)
-40°F (-40°C)
(at 20-amp load)
Mfg Part No.

Description

Operating
Voltage

Current

80028

1001

Low Battery Alarm

Adjustable 11.1V to 12.5V

NA

80029

130512

Low Battery Switch

12V

20

- power switch turns off
* Microprocessor controller and solid state output
with over-current shutdown
* Standard automotive relay pin format
* Compact size with panel-mount bracket
* Durable metal case
* 1 ⁄ 4" male tab contacts
185°F (85°C)
-40°F (-40°C )

Electronic Low Voltage Disconnect

* Preserves battery charge and protects battery banks by automatically disconnecting
loads when battery voltage drops to a critical level

Electronic Timer for Interior Lighting

* Unit prevents the internal lights inside from being left on and draining the battery
* Vehicle operator operates a momentary switch, which turns lights on
* After 20 minutes the FlexMod™ flashes the lights and gives the operator warnings to
either exit or reactivates the timer before the lights go out

Smart Battery Isolator Controller

* Monitors two battery banks and controls one or more relays to make sure starting

Heat Shrink
Products

power is protected by isolating the starting and auxiliary battery banks

Electronic Voltage Sensing Relay & Timer

* Monitors both battery voltage and ignition status, shutting down non-critical loads

when the cutoff voltage is reached, or at the set time after the ignition is turned off

* Timer and voltage sensor in one easy-to-connect unit
Stock No.

Description
Electronic Low Voltage Disconnect

48610

75526

Electronic Timer for Interior Lighting

48636

75527

Smart Battery Isolator Controller

48540

75528

Electronic Voltage Sensing Relay & Timer

12V or
24V

Mfg Part No.

75525

Stock No. 80031

Lights &
Accessories

- power switch turns off

* If voltage drops <11.8 with the timer running

Switches
& Relays

power input

* If voltage >13.25 - power switch turns on
* If voltage drops < 12.8 - time delay is started
* If voltage remains < 12.8 until the timer expires

* Small robust electronic modules that can be programmed to do almost any job
* Ultra low 1mA standby current
* Rated for more than 1,000,000 on-off cycles
* Provides overvoltage and overcurrent protection to every direct load in that circuit
* Small lightweight sealed design

48541

Stock No. 80030

Battery
Management

* Continuously monitors voltage level of a 12 volt

Cole Hersee Flexmods™

Fuses &
Circuit Breakers

Low Voltage Disconnect Switch with
Shut-Off Timer

Tapes &
Chemicals

Stock No.

* Use with Amphenol AT06-08SA,
Time Delay Value

Max Current

80030

0-60 minutes adjustable

15 amps

80031

5 minutes fixed

Waytek Stock No. 38178

Cable Ties

Stock No.

20 amps

Call Toll Free 1-800-328-2724

email: sales @waytekwire.com

®

®

107
Waytek Catalog 227

Table of Contents for the Digital Edition of Waytek Catalog 227
